2020 Toyota Corolla electrical system problems

“The contact owns a 2020 Toyota Corolla. The contact stated that while driving at an undisclosed speed, a "Maintenance Required" message was displayed, and the front passenger air bag warning light illuminated. The speedometer was inoperable. The contact stated new tires had been installed previously. The vehicle was taken to the dealer; however, the vehicle was not yet diagnosed. The contact associated the failure with NHTSA Campaign Number: 23V865000 (Air Bags); however, the VIN was not included. The manufacturer was notified of the failure by telephone. The failure mileage was approximately 67,000.”

“I am reporting a severe, recurring safety hazard on my 2020 Toyota Corolla. The vehicle suddenly displays 'Drive-Start Control Malfunction' and completely cuts off engine power in motion, leaving the car stranded in active traffic. This happened after accelerating from a STOP sign on a main avenue. This is an inherent manufacturing defect present since delivery. In total, this chronic electrical surge has burned through 6 batteries and 3 Engine Control Modules (ECMs) at different mileages. Within the first weeks of purchase, it burned its first battery, which was replaced at Toyota and documented under the VIN history. Dealer staff deceptively called it 'normal,' leading me to replace subsequent batteries at AutoZone. [XXX] Toyota received the vehicle 4 times for this exact failure under Service Advisor [XXX]. They replaced the ECM twice, replaced a destroyed battery on a third visit just 400 miles later, and during this fourth visit on XXX, they only diagnosed the current burned ECM. Under Order XXX, I paid for 4.5 hours of specialized diagnostic labor, but the shop negligently just swapped parts and ignored the root cause. On XXX, an Operations Chief from…”

“I am unable to lock or unlock the driver’s side door of my 2020 Toyota Corolla using the key fob because the door lock actuator is no longer functioning properly. I must manually use the physical key to lock and unlock the driver’s door. I consider this a significant safety concern because the power locking system is no longer functioning as intended, potentially affecting my ability to quickly secure or access the vehicle, particularly in an emergency. I have contacted Toyota directly to report the issue and request assistance with the repair, but Toyota is currently declining to cover the repair. I am proceeding with having the vehicle repaired independently because I need the door lock system restored to proper working condition. I have also learned that other Toyota owners have reported similar premature failures involving the door lock actuator. I am requesting that NHTSA document and review this complaint to determine whether this represents a recurring defect or potential safety-related problem that warrants further investigation.”

“My Engine Maintenance light came on around 59,400 miles for my Coolest Control valve !! Needed it to be replaced! Light won’t go off just had it serviced for an oil change before this started!!”

“DESIGN FLAW & SAFETY RISK: Toyota critically mismatched the standard battery to the vehicle's electrical charging profile; an AGM battery should be specified from the factory. Engine programming drops alternator voltage during cruising, deeply discharging the battery, and forces high-voltage surges (15V+) into it during deceleration. Because standard batteries cannot handle these rapid recharge loads during deceleration, the internal thermal load routinely overheats and boils the liquid electrolyte, even when brand new. This continuous boiling vents volatile hydrogen gas and discharges corrosive battery acid inside the engine bay. This structural flaw culminated in an immediate safety hazard when the battery physically exploded under the hood, creating a severe risk of engine compartment fire, chemical acid burns, and complete vehicle electrical blackout in active traffic. COLLATERAL DAMAGE & HISTORY: The chronic discharge and boiling of highly corrosive battery electrolyte severely damaged and corroded surrounding critical vehicle components. The acid completely corroded the transmission mount, the metal battery holder restraint, and the body paint.…”

“The contact purchased a 2020 Toyota Corolla. The contact stated that they discovered a mileage discrepancy after the purchase. The vehicle was a private sale on Facebook market. At the time of purchase, the vehicle mileage was 52,000. It was later discovered that the vehicle’s title mileage was 132,000. The contact stated went the DMV, and he discovered the mileage 132,483.”