2013 Toyota Highlander steering problems

“Steering column cracks, no help from Dealer. Many complaints on internet. Remedy requires expensive new steering column. Defective spindle type bearing defective. The noise is ongoing. It feels like its going to break. Very scary...ongoing doesn't stop. Dealer says wont break just replace if you want to... Toyota Service bulletin #T-SB-0034-13 details steering column replacement fix issued on this. I have it. Dealer denies simple joint grease kit maintenance option.”

“When I turn the steering faster than a certain speed, it will lock up for a moment, either turning right or left. Sometimes a light indicating a steering fault lights up on the dash cluster, sometimes not. When the turning of the wheel stops and locks up I cannot turn any more in that direction. I can turn the other way. This has been a problem for sometime and is becoming now worse. Aside from the locking up, justing turning slowly, there is a bit of a whine or low level grind sound in the sound of the steering column. This is a mechanical noise, not the typical whine of the steering pump.”

“- The car was purchased in 2015 used and the steering wheel has made a clunking sound when turning a hard sharp left or right since the day of purchase -While on a road trip of approximately 3,000 miles round trip in June 2021 the steering wheel was adjusted to accommodate my husband's height. It became very loose, with it finally dropping into my husband's lap on the last day of our trip-it was difficult to steer the car -We brought the car in to our dealership the following day where they confirmed we needed a new steering column-the car has not been involved in any accidents nor have the air bags employed -Other than the "clunking" sound there has never been any previous warning that the steering wheel would disengage while driving.”

“THERE ARE SOUNDS WHEN SOMETIMES WHEN TURNING, INCLUDING POPING OR SOMETIMES LIKE A WHIRLING SOUND. THE STEERING IS A BIT STIFF SOMETIMES AND NOT EASY TO TURN THE WHEELS, THIS DOES NOT HAPPEN AT ANY SPECIFIC SPEED. I DO NOT HAVE ANY PICTURE OR OTHER DOCUMENT I CAN UPLOAD AS THIS IS NOT PHYSICAL DAMAGE THAT CAN BE PHOTOGRAPHED.”

“INTERMEDIATE STEERING SHAFT - NOISE BEGAN AROUND 60K MILES AND HAS CONTINUED TO GET WORSE, NOW AT 104K. IF TOYOTA KNOWINGLY MADE A DESIGN CHANGE AND ISSUED A NEW REPLACEMENT PART, RECALL SHOULD BE ISSUED.”

“'THUNK'/POPPING NOISE WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT. WAS TOLD TO REPLACE THE INTERMEDIATE STEERING SHAFT, AND LEARNED THAT A NEW ONE WAS DEVELOPED TO FIX THIS PROBLEM IN 2013 BUT NO RECALL OR SAFETY NOTICE WAS SENT TO OWNERS.”