2015 Toyota RAV4 electrical system problems

“While driving my 2015 Toyota RAV4 XLE 2WD (2.5L, about 207,000 miles), the electric power steering assist failed instantly with no warning, making the steering wheel feel locked. At the same moment, the infotainment screen went black and rebooted. It has happened at freeway speeds and at low neighborhood speeds, including on 9/14 and 9/15/2026, and also more than once last year (2025). No warning light or messages appeared beforehand. An OBD2 scan at AutoZone on 9/15/2026 found no active or pending trouble codes, and battery tests at AutoZone and Walmart Auto Care passed. The problem has not been reproduced or confirmed by a dealer. The failed component is UNKNOWN. My best assessment is the EPS control unit, because the symptoms match NHTSA recall 15V144000. I only learned of this recall on 9/19/2026. A sudden loss of steering at any speed puts me and other drivers at serious risk of a crash. The vehicle is available for inspection.”

“The contact owns a 2015 Toyota Rav4. The contact stated that the radio was inoperable. The contact stated that the gauges failed to properly operate. While driving 65 MPH, the vehicle lost power steering functionality. Additionally, the rearview camera image was reversed before becoming inoperable. The ABS, AWD, and engine warning lights were illuminated. The vehicle was taken to an independent mechanic, and an undisclosed fuse was replaced. The mechanic made the contact aware of NHTSA Campaign Number: 15V144000 (Steering). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and scheduled an appointment with the dealer for the recall repair of NHTSA Campaign Number: 23V734000 (Electrical System). The failure mileage was approximately 189,000.”

“On Friday February 27, 2026 as the vehicle was being driven it caught fire. Fire department and sheriffs office was called to the scene. Vehicle fire was put out but the whole front end burned.”

“When we bought the SUV, it had a small top battery installed. The battery slid over and caused my alternator to go out completely. I must have caught fire, as there were burnt wires to the alternator. We replaced the alternator, and it was over $295 dollars and then had to get a new battery, and that was over $150 dollars. I installed it myself because I am a mechanic.”

“The contact owns a 2015 Toyota Rav4. The contact stated that while the vehicle was parked or being driven, water was leaking into the vehicle from the roof, causing water damage to the electrical wiring to the air bags. A dealer was contacted. The vehicle was taken to the dealer, where it was determined that there was a hole in the roof and that the roof needed to be removed for a proper investigation. The contact was informed that the air bags could unintendedly deploy unintentionally if not repaired. The vehicle was not repaired. The manufacturer was notified of the failure via letter and phone calls, and the contact was informed that the case had been closed. The approximate failure mileage was 65,000.”

“The contact owns a 2015 Toyota Rav4. The contact stated that while operating the vehicle, the battery, ABS, and brake warning lights illuminated, and the vehicle stalled on several occasions. The vehicle was jump-started, and the vehicle operated normally. Additionally, the steering wheel became difficult to turn on several occasions. The vehicle was taken to the local Auto Zone which replaced the battery, but the failure persisted. The local dealer was notified of the failures, but no assistance was offered. The cause of the failure was not determined. The manufacturer was not contacted. The failure mileage was 110,000.”