Problems · by component
2007 Toyota Tundra structure problems
61 owner complaints to NHTSA about the 2007 Toyota Tundra cite structure, 16% of all 390 complaints for this model year.
Complaints
61
16% of all complaints
Crashes
1
Reported by owners
Fires
1
Reported by owners
Injuries
1
Reported by owners
What owners say about the structure
Verbatim from NHTSA complaints, newest first
“The contact owns a 2007 Toyota Tundra. The contact stated while parking the vehicle, there was a loud sound coming from the vehicle. The contact inspected the vehicle and determined that the fuel tank scrap and bolt had fractured and detached. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. In addition, the contact stated that when the vehicle was purchased in May 2024, the contact later noticed flaking material on the ground underneath the vehicle. The vehicle was then taken to the dealer, but no assistance was provided. The manufacturer was made aware of the failure and a case was filed. In addition, the contact confirmed that in March 2019, the vehicle was serviced under an unknown corrosion prevention recall repair. The contact confirmed that at the time, the dealer performed the recall repair by spraying anti-corrosion prevention on the suspension. The unknown recall repair was warranted for 60 months. The failure mileage was approximately 279,000.”
“The contact owns a 2007 Toyota Tundra. The contact stated that occasionally while driving at various speeds on bumpy road surfaces, the fuel tank was scraping against the pavement. The contact stated that upon inspection from the outside, the contact became aware that the fuel tank was hanging abnormally low and the bracket holding up the brake lines and fuel lines were completely rusted. There were no warning lights illuminated. The vehicle was taken to an independent mechanic to be diagnosed, and the contact was informed that due to the abnormal amount of rust on the sub frame, the vehicle was not safe to be driven. The contact was informed that the entire sub frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 142,255.”
“Undercoating of vehicle was not properly installed causing the frame to rust out creating a serious safety concern as the fuel tank can fall from the vehicle due to extensive rust. Toyota is aware of this situation however refuses to repair the problem.”
“The frame of the vehicle has a recall on it because of excessive rusting. The previous owner had not gotten the recall fixed. The rusted frame causes issues with steering, maintenance, and general control and safety of the vehicle. Toyota dealerships claim this recall has expired. A rusted frame violated NY State inspection. Since this indefinitely violates the NHTSA guidelines and regulations, how can it expire? Toyota refuses to fix the recall on the frame due to “expiration” and would rather endanger roadways see as many of these vehicles still are driven on public roadways and come with a hefty cost due to the expiration. Many vehicles like this with under 100k miles have the same critical issue, leaving Americas at a loss. This recall should not “expire””
“What component or system failed or malfunctioned, and is it available for inspection upon request? Gas tank cover plate is rusting out causing the tank to almost fall out. How was your safety or the safety of others put at risk? My safety and others safety was put at risk as if the tank were to fall out, it could catch the vehicle on fire. Also as the plate rusts even more day by day, the heat from the exhaust and other parts that heat up it can damage the gas tank and once again is a fire hazard. Has the problem been reproduced or confirmed by a dealer or independent service center? No, there are no open recalls from what I can’t tell by the vin but same year has same problems and are under recall. Not sure why this one isn’t under recall. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there would be no lights for an issue like this.”
“The frame is shot on my 07 Toyota tundra the frame rails has several big holes in the frame as well all the crossmembers are rusted and I’m still currently paying on the truck I still owe $14,000 on it and I can’t afford to get it fixed so will you please please please help me out with this situation and either open the recall up or see if I can qualify for the assistance program I’m paying on a vehicle I cannot drive it’s unsafe to drive and the issue needs fixed the recall or whatever it’s was called should’ve never been expired to begin with and I wasn’t even aware of the recall had I was I would’ve got it fixed !! I’m begging you please help me as my family relies on this on truck I have !! Thank you and have a nice day !!”
Showing 6 of 61 reports. Read every report on NHTSA.gov.
Data from NHTSA Complaints API (owner reports, unverified) · synced Nov 10, 2026NHTSA vehicle page
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.