2006 Volkswagen Passat service brakes, hydraulic problems

“I WAS TRAVELING SOUTHBOUND ON THE MAINE TURNPIKE AT 55-60 MPH DUE TO SOME BLACK ICE IN AREAS. TEMP WAS 35, CONDITIONS WERE CLEAR, VISIBILITY GOOD. AFTER PASSING EXIT 75, WITHOUT WARNING MY VW PASSAT ELECTRONIC PARKING BRAKE ENGAGING, CAUSING MY BRAKES TO LOCK UP AND CAUSING ME TO LOOSE CONTROL OF THE VEHICLE, SWERVING SIDE TO SIDE FOR APPROXIMATELY 50 YARDS. DURING THIS TIME, THE PARKING BRAKE LIGHT WAS FLASHING AS WELL AS A PARKING BRAKE FAULT MESSAGE ON THE DASH WAS DISPLAYED. I WAS ABLE TO REGAIN CONTROL OF THE VEHICLE AND PULL OFF TO THE SHOULDER. I PUT THE VEHICLE IN PARK, REFERRED TO MY MANUAL, WHICH WAS NO HELP. I GOT OUT OF THE VEHICLE, LOOKED AROUND IT AND THEN CALLED A FEW PEOPLE TO DISCUSS THE PROBLEM. NO ONE HAD EVER HEARD OF THIS ISSUE BEFORE AND I SAW NO OBVIOUS SIGN OF ERROR. THIS VEHICLE IS EQUIPPED WITH AN ELECTRONIC PARKING BRAKE BUTTON ON THE DASH. I BELIEVE ITS ELECTRONIC MALFUNCTION AND A HUGE SAFETY ISSUE. IF THERE WOULD HAVE BEEN VEHICLES NEAR MINE, WE WOULD OF COLLIDED. I HAD MY DAUGHTER AND HER FRIEND IN THE REAR OF THE VEHICLE AND WE WERE ALL VERY SCARED DURING THIS ENTIRE INCIDENT. AFTER 10 MIN OF SHUT OFF, I RESTARTED, THE DASH STILL…”

“AT THE MORNING OF 3/30/2012 WHILE WAS DRIVING TO WORK BRAKES FEEL FUNNY( SOMETIMES LIKE HARD, SOMETIMES SOFT) STARTED THAT MORNING. WHILE I WAS BARKING MY CAR BRAKES FAILED, HARDLY STOPPED AND CRASHED TO ELECTRIC POL. BROKE FRONT GRILL AND EMBLEM PUT A DENT ON CHROME PIECE ON THE FRONT.I TOOK THE VEHICLE TO DEALER. FOUND BRAKE BOOSTER NEPRENE HOSE HAD MULTIPLE CRACKS.. THAT REPLACEMENT SHOULD BE FREE BUT THEY CHARGE ME SOME$200.00. I WOULD LIKE TO COMPLAIN VOLKSWAGEN OF AMERICA. GOOD THINK DID NOT HAPPENED ON HIGHWAY 70 MPH. *TR”

“I BEGAN TO HAVE PROBLEMS WITH THE ENGINE LIGHT. EVERY TIME I HAD IT CHECKED, IT CODED SOMETHING DIFFERENT (PO455, PO171, PO441) WITH THESE RESULTS: FUEL CAP LIGHT CAME ON, HIGH PRESSURE FUEL PUMP, EVAPORATIVE EMISSION CONTROL SYSTEM , AND LEAN BANK 02 CENSOR BEFORE THE CATALYTIC CONVERTER. IT BECAME HARD TO CRANK, AND ONCE SHOOK WHEN IT DID CRANK. THE STEERING WHEEL MODULE AND COMFORT CONTROL MODULE WERE REPLACED IN 2008 UNDER WARRANTY AFTER I TOOK VOLKSWAGEN TO SMALL CLAIMS COURT. I TOOK THE CAR TO A DEALERSHIP IN ATLANTA (THERE ISN'T ONE CLOSE TO WHERE I LIVE) AND THEY COMPLETED THE FOLLOWING REPAIRS: CODE PO444, THE EVAPORATIVE EMISSION SYSTEM PURGE CONTROL VALVE CIRCUIT; CODE PO193, FUEL MEASURING SYSTEM 2 ABNK 1; AND P2187 SYSTEM TOO LEAN AT IDLE. TOTAL= $884.84 ($619.95 LABOR; $204.31 PARTS; $43.25 WASTE DISPOSAL CHARGE; AND $17.33 TAX). AT NO CHARGE, THEY CHECKED THE PASSENGER HEADLIGHT WHICH I HAD TO REPLACE @ TWICE A YEAR AND INSPECTED HIGH PRESSURE PUMP, GFF GUIDED FUNCTIONS AND A COURTESY VISUAL SERVICE INSPECTION. *TR”

“SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM 2006 VW PASSAT 3.6L VR6 MODEL. THE PROBLEM OCCURRED IN LATE 2010 AT FIRST A FEW MONTHS AFTER THE CAR WAS PURCHASED. THE PROBLEM OCCURS WHEN THE VEHICLE IS AT A SET OF LIGHTS, THE RPM ARE NORMALLY AROUND 650-700 RPM, WHEN THE PROBLEM OCCURS THE RPM GO TO 1250-1300 WHILE THE VEHICLE IS STOPPED, THIS MAKES SO THE DRIVER HAS TO APPLY MUCH MORE FOOT STRENGTH TO HOLD THE CAR. RAISING THE RISKS OF A CAR CRASH. THIS HAPPENS RANDOMLY, IF I DRIVE A DAY IT MIGHT NOT HAPPEN, THEN I DRIVE THE NEXT DAY AT THE SECOND SET OF LIGHTS IT HAPPENS. I HAVE ATTEMPTED TO REPAIR THIS AT VW IN NH BUT THEY DID NOT SOLVE THE PROBLEM AND CLAIMED THE CAR "IS NOT REALLY AN AUTOMATIC, BUT A MANUAL" AND CHANGED GEAR BOOT CONNECTORS OR SOME SOMETHING, AND THE SAME WEEK THE PROBLEM RESUMED. I FEEL I CANNOT GO TO VW TO REPAIR THIS AS THIS WILL GIVE ME EXCUSES, PLEASE LOOK INTO THIS, I FEEL THIS IS DETRIMENTAL TO MY AND MY FAMILY'S SAFETY. THANK YOU. *TR”

“I OWN A 2006 VW PASSAT 3.6, ENGINE DIED SUDDENLY AFTER PULLING OUT ACROSS A 45MPH STATE ROUTE, AFTER ENGINE FAILED, THERE WAS NO STEERING OR BRAKES, HAD TO PUSH CAR OUT OF TRAFFIC WITH MY 2 YOUNG SONS INSIDE. YOUNG VW, EASTON PA. STATED THE FAILURE AS A OIL PUMP BOLT THAT HAD BACKED OUT AND SHEARED OFF, CAUSING THE CATASTROPHIC ENGINE FAILURE. AFTER SOME RESEARCH I FOUND 58 FAILURE OF THIS TYPE OF THIS SAME YEAR AND ENGINE, AT: HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?3462993-ATTN-3.6L-OWNERS-HAS-YOUR-ENGINE-FAILED , - THIS IS CLEARLY AN ISSUE VW WAS AWARE OF SEVERAL YEARS AGO, AS EVIDENCED BY THE REPLACEMENT OR REPAIR OF SO MANY, 58+ ENGINES THAT I CAN DOCUMENT, AND CHOOSES NOT TO RECOGNIZE THE ISSUE, I BELIEVE DUE TO FINANCIAL REASONS AS THIS FIX IS $3,000 IN LABOR ALONE. I CONTACTED VWOA, (REF. # [XXX]) AND VW AG, (,REF. NO.: [XXX]) WITH THIS ISSUE AND NEITHER HAD RECOGNIZED THIS AS A KNOWN ISSUE, MY VEHICLE IS OUT OF WARRANTY, AND VW ESTIMATED THE REPAIR AT $12,800 FOR A REBUILT ENGINE. ASIDE FROM BEING ABUSIVELY EXPENSIVE, THIS FAILURE SHOULD NOT BE ALLOWED TO OCCUR RANDOMLY, IN TRAFFIC OR ANYWHERE CREATING A VERY UNSAFE AND LIFE THREATENING SITUATION,…”

“TL* THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT WAS ATTEMPTING TO PULL INTO A PARKING SPACE WHEN THE BRAKES FAILED. A LOCAL MECHANIC STATED THAT THE HEAT SHIELDS ON THE TURBO FAILED, CAUSING THE BRAKE FAILURE. THE VEHICLE WAS REPAIRED UNDER THE CONTACT'S FACTORY WARRANTY. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 47,000.”