2013 Volkswagen Passat fuel/propulsion system problems

“The vehicle was brought to Bill Jacobs Volkswagen in Naperville, IL to have three open, mandatory federal campaigns and emissions modifications completed. The dealership is actively practicing illegal 'recall steering' by holding the vehicle hostage. The service department refuses to perform the free federal campaigns unless the owner first authorizes between $2,500 and $3,000 in unrelated diagnostic and repair fees out of pocket. The dealership falsely claims that the vehicle must be 'brough to specification' at the owners expense before a federal safety or emissions campaign can be completed, which directly violates federal regulations prohibiting dealerships from conditioning or delaying mandatory factory campaign work based on customer-paid services. Furthermore, dealership staff ignored explicit, repeated verbal warnings regarding an active Adblue countdown, shut the vehicle off, bricked the car via a 'No-Start' lockout inside their active service lane, and are now refusing to release the vehicle or keys without unapproved fees. The active check engine lights on the vehicle are directly tied to the faulty emissions and NOx sensor components that the open…”

“I was on top of Beech Mountain NC working at a customer's house when it started to snow. I was at the bottom of their driveway and when I attempted to drive out, the traction control light would turn on, indicating I was losing traction. When this happened, I was unable to accelerate any more and the car started sliding backwards. So sitting in the car in the snow, I pulled up YouTube to figure out the "procedure" to disable traction control so I could get more speed. Turn the car off, ignition on, activate the flashers, push the brake pedal multiple times, then start the car. Traction control disabled, so "simple"! The only problem is once the car starts moving traction control gets enabled again and I'm sliding backwards again! Extremely dangerous on a mountain! Eventually I was able to clear the snow enough and just hold down the accelerator to power out. So now my GPS is telling me I have to drive up a hill to get off the mountain. Same problem: I start up the hill, traction control kicks on and I lose ALL power and begin to slide backwards! Luckily I am a good driver because I was able to control the slide and do a 180 in the middle of the road. So my GPS…”

“High pressure fuel pump failed, causing the car to completely shut down on the Highway. Because of the systems design, it sends fragments into the fuel lines and fuel injectors clogging them. The Passat TDI uses the CP4 HPFP that has already been recalled by FCA and BMW. I was unaware how common it is for this fuel pump fail and the complete destruction it causes to the fuel system.”

“The vehicle cuts off while driving we’ve done numerous expensive replacements to water pump, control arm bushings, new battery, variable valve timing, celinoid, camshaft adjustment magnet, spark plugs and coils, ignition switch, fuel pump, gas cap. Oil filters And there is still a problem.”

“On [XXX] at 6 a.m. I was commuting NB on [XXX] , when engine lost power on 5 lane highway after driving over rough patch of road (~1 mile S of [XXX]). I barely got car onto right shoulder from middle lane when car shut off. Glow plug pigtails warning light came on right as I experienced significant decrease in engine power. AAA towed car to VW Dealer. Diagnostic performed on 7/5. I was informed of catastrophic failure of fuel pump, metal had gotten into fuel lines and tore up. My entire fuel system needs to be replaced. Dealer quoted $7K to repair. Car had never displayed signs of fuel issues. Car is well maintained and gets regular service at dealer. Upon investigation, I see VW had several years with high pressure fuel pumps failing. This needs to investigated/addressed as these failures are still occurring in cars that are 2013 and newer. I have requested dealer to send me pdf of repair estimate.”

“Took my car to Heritage.Volkswagen in 2022. They said the fuel tank needed replaced. Had engine light on and epc light on. They replaced the the upper and lower fuel tanks. When I picked up my car it still had the same problem. Still have the same lights on.I get hesitation when the car gets to the 2 ohms mark. I have to add fuel injection cleaner often.”