2022 Volkswagen Tiguan engine problems

“I am having an engine oil consumption issue while I was in warranty and now being a few thousand miles out of warranty. Volkswagen states having to top off a quart of oil within 600 miles is tolerable. I have had to top off the oil 6 times between oil changes so far. The dealership states that VW of USA denies any repairs and there hands are tied. They know it's a cylinder head issue but since the issue is not catastrophic (engine seized or more than a quart burning) they will not fix it.”

“I am reporting a serious engine defect on my 2022 Volkswagen Tiguan at approximately 39,500 miles. The vehicle has excessive oil consumption and an oil leak. The authorized dealer diagnosed the problem as requiring full cylinder head replacement. This is a major engine repair at low mileage. I previously told the dealer the vehicle needed oil added between changes. The issue has worsened and now requires a cylinder head. I escalated with dealership management and Volkswagen Customer Care. Volkswagen refuses full coverage and offers only partial goodwill, leaving me to pay a large portion out of pocket despite the low mileage. This issue is widespread on 2022–2023 Tiguan models with the 2.0 TSI EA888 engine. Multiple owners report the same oil consumption and cylinder head replacement. Consumer Reports has documented cylinder head and oil consumption complaints on the 2022 Tiguan. Class action lawsuits allege a defect causing excessive oil consumption. The Canadian Automobile Protection Association has also reported premature valve guide wear leading to cylinder head replacement on 2018–2024 Tiguans. Excessive oil consumption creates a safety risk. Low oil can…”

“I have only ever serviced this vehicle at VW dealerships, and took the car in for service every 10k miles. The check engine light came on just under 50k miles and it was due to a cracked Leak Detection Pump. I paid for the repair out of pocket. After it was fixed, just a few weeks later the check engine light came back on. When I took the car back to the same dealership, they diagnosed the problem as a cylinder head issue requiring cylinder head replacement and quoted a significant cost to fix. It is not covered under warranty even though I am just barely over the 50k mile mark. There is a common and known, recurring issue with the engine on the 2022 VW Tiguans and it is a shame that there is no recall already issued for this.”

“EPC light kicks on which is puts your car in limp mode, which is caused by a cylinder head issue. The EPC limits your car acceleration and speed ability, this is extremely dangerous especially on the highway. It’s been a year & Volkswagen is refusing to take responsibility and offer a recall when it’s an ongoing issue with 2021-2022 Volkswagen Tiguans. The cylinder heads have been on back order for a year. This is an issue I believe that needs a nation wide investigation & recall for customers.”

“I own a 2022 Volkswagen Tiguan that has experienced ongoing excessive oil consumption. At approximately 60,000 miles, the vehicle experienced a much more serious incident. While traveling approximately 75 mph on the interstate, the vehicle began actively spraying engine oil, covering the exterior of the vehicle. A warning light then appeared instructing me to check the engine oil level. I was able to exit the interstate and pull into a gas station. Once parked, the vehicle was leaking an excessive amount of oil onto the concrete underneath it. I contacted the dealership, and they immediately understood the issue because they had seen the same problem occur in other Volkswagen Tiguans. I am concerned that the sudden and substantial loss of engine oil while traveling approximately 75 mph presents a serious safety risk. This type of failure could potentially cause catastrophic engine damage or engine failure at highway speeds, leaving the vehicle disabled in active traffic. I am also concerned about the possibility of oil contacting hot engine components and creating a fire hazard. This incident is especially concerning given the vehicle's prior history of…”

“I got this car in 2024 and it burns through oil. I am constantly replacing the oil and have had to have the seals replaced a couple of times. Every 200 to 300 miles I have to put oil in it. It’s too new of a car for that. I know a lot of other owners have had issues.”