2022 Volvo XC60 B6 problems

“This has happened multiple times, confirmed by the dealer that it is a know issue with no fix. While driving down the road, the digital dashboard goes completely blank. No speedometer, no fuel guage, nothing. Very dangerous when driving to not know the speed that you are travelling. Also, all audio cuts out - no blinker signal sounds, no radio, etc. Less concerning is the infotainment system going completely black and silent as well - radio, maps, climate control. There have been multiple recalls performed but the dealer but none of them has fixed the issue. This must be a MJAOR safety concern when the dash does completely blank while traveling 65mph down the highway.”

“At the end of a downhill cloverleaf coming coming on and off a highway, the car slowed to a crawl but would not stop. It was going slowly as if "creeping" like when in B mode but was not in B mode. The brakes would not stop it. I was able to shift gears from Drive to N to P but no response, car continued to creep forward until it gently bumped into the back of an 18 wheeler. There was no collision alarm at the time. I turned the car on and off, and powering down seemed to re set the issue, but the collision alarm went off like 10 minutes later when there was nothing to set it off (seemed like it was just delayed). No error code came up, nothing. I submitted my claim to Volvo, esp since there are similar recalls so I thought it was a known thing, but apparently not reported on my exact make and model (there were not very many made). I did not know there was damage to my vehicle, and the truck driver and myself did not even get out, he didn't feel me, and I assumed the bumper just bumped him so no police report. This was an intermittant failure and after I re booted the vehicle I slowly drove home after brakes seemed to be working after power on/off. I did not…”

“Turn signal audio not present (lights working. No audio from radio, phone , collision warnings rear cross traffic warnings, door ajar audio warnings. Resetting the display fixes the problem. However, the issue returns the next day.”

“Component Failure & Inspection Availability: Infotainment Head Unit (IHU) / Audio Module (AUD) running Android Automotive OS. The vehicle and its components are available for inspection upon request. Safety Risk: The audio system completely crashes approximately every 3 drive cycles. This failure disables all safety-critical audio features, including turn signal clicks, backup camera and parking sensor chimes, blind-spot/cross-traffic warning alerts, and emergency system tones. Operating the vehicle without audible turn signals or proximity chimes creates significant driver distraction and an immediate hazard to traffic safety. Dealer / Service Confirmation: The issue occurs intermittently during daily operation and is being reported to Volvo dealer service Prior Inspection: The vehicle has been inspected by Volvo service department Symptoms & Onset: The problem began following a recent Android Automotive OS software update. No warning lamps, error messages, or indicators appear prior to the failure. The entire audio bus shuts off either at vehicle start or mid-drive. The only temporary workaround is forcing an infotainment reboot by holding the center display…”

“On [XXX], at 82,371 miles, my daughter's 2022 Volvo XC60 T8 Recharge was diagnosed with DTC BECM-P0BBD92 (Hybrid/High Voltage Battery Pack Voltage Variation) and a confirmed Cell Module F failure (Repair Order #[XXX], Bob Penkhus Motor Co Volvo Cars, Colorado Springs, CO). The dealer instructed her not to charge the vehicle pending repair. The replacement part (Cell Module F, Part #36003341) has been on indefinite backorder since diagnosis — initially quoted at 6 weeks, still unavailable as of this report. This vehicle falls within NHTSA Recall 25V-179 (LG high-voltage battery modules, fire risk when fully charged and parked). NHTSA's VIN lookup shows this VIN as having no unrepaired recalls, which I believe reflects only a prior software-monitoring update rather than a physical hardware fix — this diagnosed cell failure occurred after that update, is consistent with the exact failure mode described in the recall, and cannot currently be repaired because the remedy part is unavailable. Volvo Cars USA opened and then closed a corporate case (#[XXX], closed June 19, 2026) declining further assistance, stating its only obligation is to repair the vehicle — which…”

“The contact owned a 2020 Volvo XC60 II. The contact stated while reversing, the rear view camera displayed a black screen. The contact stated that the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The vehicle's speed independently accelerated. The contact's vehicle crashed into a parked vehicle. The contact stated that there were two additional occupants in the vehicle. The contact sustained pain in the right knee, no medical treatment was provided. The passenger, who was seated in the rear seat, sustained neck and upper back injuries. The passenger received medical treatment at the local medical center. The vehicle was driven to the residence. The failure was intermittent. The contact stated that the vehicle was previously taken to the dealer, however the failure was not duplicated. The contact later received a recall notification, NHTSA Campaign Number: 25V908000 (Back Over Prevention). The manufacturer was not made aware of the failure. The failure mileage was 40,000”