2005 Volvo XC90 electrical system problems

“I was getting off the highway and made a left turn. As I was accelerating the motor gentle cut off.. (You wouldnt even notice if you wasnt driving) Full Traffic was behind me, so luckily I was able to get out of the way and pull to shoulder. It was the day before Christmas and car hasn't ran since. Upon investigation I found the CEM was effected. When the car died I was in left hand lane and I had to make my way to right, the shoulder. Yes the problem was diagnosed by myself. However I did investigation and researched using all data at library. It has not been inspected by anyone else. There where no warning lamps or messages prior to the failure. It happened all of a sudden in the middle of traffic when I was getting off the highway.”

“I HAD FILLED AN EARLIER COMPLAINT AND THIS TO BE ADDED TO THE EARLIER FORM THAT I HAD FILLED NEEDS TO GO TO THE ENGINEERING DEPARTMENT. SEE PHOTO THE ELECTRICAL COMPLAINT FROM THE MAGNETIC ELECTRICAL BEINGS IN ME AND IN THIS PICTURE I BELIEVE IS ABOUT DESIGN OF THE FUSES IN VEHICLE AND WHAT THEY ARE TRYIN TO COMMUNICATE HERE I BELIEVE WOULD BE THE DISTANCE BETWEEN THE POSITIVE AND NEGATIVE CONNECTIONS LIKE WHAT IT IS DOING TO THEM AS IT GOES THROUGH THOSE TYPES OF FUSES. WHAT I BELIEVE TO BE WHAT HAPPENS TO THEM IN THOSE PLASTIC FUSES AND WOULD LIKE THEM THE FUSE TO BE DESIGNED FURTHER APART A LITTLE BIT BIGGER THAN A PENNY AND WITH THE CONNECTION STRAIGHT ACROSS AND NOT GOING UP AND DOWN AND BACK THROUGH IT SELF. THE MAGNETIC BEINGS WOULD LIKE TO SEE THE CONNECTIONS STRAIGHT ACROSS SO THAT THEY DON'T INTERFERE WITH EACH OTHER WHILE TRAVELING THROUGH THE SUBSTRAIGHT. NOT SURE BUT YOU WERE THIS TYPE OF BEING YOU WOULD TRY AND COMMUNICATED THESE THINGS AND DESIGN WELL JUST LOOK AND IF YOU WOULD LIKE THEY LIKE THE OLDER GLASS FUSE WITH THE STAINLESS STEEL DESIGN. IF YOU COULD THEY ARE ASKING THAT YOU THE NTSB GO BACK REDESIGN A FUSE THAT DON'T GO BACK INTO ITSELF…”

“TL* THE CONTACT OWNS A 2005 VOLVO XC90. EVER SINCE THE VEHICLE WAS PURCHASED IN NOVEMBER OF 2018, THERE HAD BEEN SEVERAL ELECTRICAL FAILURES. THE HEADLIGHTS, POWER DOOR LOCKS, AND POWER REARVIEW MIRROR FAILED TO OPERATE. ALSO, THE TRANSMISSION CAUSED THE VEHICLE TO JERK AND STALL WHILE DRIVING. THE CONTACT TOOK THE VEHICLE TO AN UNKNOWN VOLVO DEALER, BUT THEY REFUSED TO PROVIDE DIAGNOSTIC TESTING AND STATED THAT THERE WAS NO RECALL OR WARRANTY COVERAGE ON THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 14,042.”

“2005 VOLVO XC90 HAS MANY PROBLEMS. TRANSMISSION JUMPS AND JERKS WHEN SWITCHING TO HIGHER GEARS. ALMOST THROWS THE CAR OFF THE ROAD AT TIMES. ALSO, VEHICLE HAS MANY ELECTRICAL PROBLEMS DUE TO CAR NOT BEING SEALED PROPERLY. THIS LEADS TO ELECTRICAL ISSUES INCLUDING FAULTY AIR BAG CODES, BRAKE LIGHTS AND REAR TURN SIGNALS GOING OUT. CAR HAS NO BRAKE LIGHTS NOR REAR TURN SIGNALS AT ALL. DEALERSHIP CAN NOT FIND PROBLEM SAYS IT IS DUE TO THE 2005 VOLVO XC90 NOT HAVING RELAYS AT ALL. AND ALSO FROM WATER BEING INTRODUCED TO ELECTRICAL PARTS.”

“THIS MODEL IS EXPERIENCING THE SAME AS RECALLS IN SIMILAR MODELS BUT FOR SOME REASON ISN'T RECALLED. FUEL SYSTEM IS FAULTY. LEAKING FUEL AND CRACKS IN FUEL PUMP. REPLACED WITH 4 PUMPS FROM VOLVO AND NOW IT IS KICKING OUT ECM CODE AND BLOWING EVERY FUEL SYSTEM INSTALLED.”

“MY 2005 XC90 (ODOMETER APPROX. 178,000 MILES) THROWS CHECK ENGINE, REDUCED ENGINE PERFORMANCE AND ENGINE SERVICE REQUIRED DASHBOARD WARNINGS INTERMITTENTLY, DESPITE THE FACT THAT IT HAS A NEW CEM AND A SECOND NEW THROTTLE BODY IN LESS THAN TWO MONTHS. IT ALSO ISSUES A LOW BEAM HEADLIGHT BULB FAILURE WARNING, EVEN WHEN THE BULB IS LIT, AND THE LEFT TURN BLINKER IS STICKY. SOMETIMES, THE DRIVER'S SEAT AND PASSENGER SIDE REAR VIEW MIRROR READJUST SIMULTANEOUSLY UPON OPENING THE DRIVER'S SIDE DOOR, WITH NO KEY IN THE IGNITION AND NO ONE SITTING IN THE SEAT. RECENTLY WHILE TRAVELING ON AN EXPRESSWAY AT 65 MPH, THE CAR ABRUPTLY LOST SPEED (A TERRIFYING EXPERIENCE) AND STRUGGLED TO ACCELERATE TO 40 MPH. A FEW DAYS LATER, IT LOST POWER IN HEAVY CITY RUSH-HOUR TRAFFIC (ALSO TERRIFYING) AS A RED LIGHT TURNED GREEN. IT BARELY MADE IT TO 10 MPH AND CAME CLOSE TO CAUSING A CHAIN REACTION CRASH WITH THE CARS BEHIND IT (ALSO TERRIFYING). LUCKILY I WAS ABLE TO STEER INTO A NEARBY BANK PARKING LOT, TURN IT OFF AND RESTART IT. IT DROVE NORMALLY BUT THE WARNING LIGHTS REMAINED. I HAVE TAKEN THE VEHICLE TO THE VOLVO DEALERSHIP MULTIPLE TIMES, CITING ELECTRICAL SYSTEM WOES, WHICH…”