2018 Alfa Romeo Stelvio problems

“I am reporting an authorized manufacturer franchise dealer for actively refusing to remedy a federal safety recall and unlawfully withholding my vehicle. My vehicle is a 2019 Alfa Romeo Stelvio (VIN: [Insert VIN]), which is subject to the active Fuel Pump Safety Recall (NHTSA Campaign 25V586000 / Manufacturer Recall Code 93C). The vehicle has been physically located at Southern Alfa Romeo of Norfolk ([XXX]) for approximately 18 months. The dealership service management has explicitly stated that they will not perform the mandatory safety recall remedy, nor will they release my vehicle to a flatbed towing company, until an unrelated $5,000 civil dispute involving a loaner car is paid out of pocket. By conditioning a federal safety mandate and the physical custody of my vehicle on a separate civil debt, this dealership is violating the National Traffic and Motor Vehicle Safety Act (49 U.S.C. Chapter 301). The 1.5-year delay also completely violates the federal requirement to provide a safety remedy within a reasonable timeframe. I request federal intervention to force compliance.”

“The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that while driving 45 MPH and merging onto the highway, the vehicle entered Low Power Mode, forcing the contact to pull over to the side of the road. The contact then drove to the residence, where the vehicle was turned off and restarted, and the messages "Service Engine" and "Service Throttle Control" were displayed. The vehicle was taken to the dealer, where the fuel system was bled. The dealer later informed the contact that the high-pressure fuel pump had failed and needed to be replaced. The vehicle was not repaired. The contact stated that the high-pressure fuel pump and the fuel delivery module (FDM) were replaced in July 2025. The contact related the failure to the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 62,000.”

“The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 24V510000 (Air Bags, Seat Belts) and 25V586000 (Fuel System, Gasoline). However, the closest authorized dealer was approximately 55 miles away and was an 1 hour and 15 minutes of driving. The dealer was contacted. The manufacturer was contacted and made aware of the issue.”

“My vehicle was subject to recall 93C for the fuel delivery module. Before the recall repair I had Auto Start/Stop Disabled, Service Electronic Throttle, Service Parking Brake, Check Engine Light, limp mode, and unexpected shutdowns. Bill Luke Tempe Alfa Romeo replaced the fuel pump on September 29, 2026, and the vehicle was ready September 30, 2026. The same warnings and shutdowns continued after the repair. On October 23, 2026, at approximately 93,400 miles, while driving to Walmart, I attempted a U-turn. The vehicle went into limp mode with the same warnings and completely shut down in the middle of the turn. I was able to restart it temporarily and move it to a Circle K parking lot, but when I tried to pull into a parking space it would not start. It was towed to my home in Tucson and has remained inoperable since. No crash, no injury, and no fire occurred. The loss of power while turning was a serious safety risk.”

“My vehicle has been subject of multiple recalls, however the current recall is a significant one and has been pending for months with no end in sight. I am concerned The manufacturer and dealers are not taking this seriously and the delay is causing additional damage to my vehicle. Additionally quickly googling my vehicle will show that it has fuel pump and acceleration jerking and lag issues that are extremely, extremely, common and troubling. I am also still having the service engine soon issues described in recalls and other forums related to throttle cable. Either none of this has been addressed by the manufacturer or the repairs so far have not been sufficient if it is still so common. On behalf of all Stelvio owners I demand these recalls and issues be addressed in a timely manner. This is going to cost us additional grief, safety issues, and repair costs. The biggest being my safety and my family's safety when we are riding in this vehicle, the acceleration issues are very noticeable and are getting worse. The symptoms are -exactly-what is described online and also as part of the recall. I don't even have the option to get it fixed there is no parts to…”

“ABS module doesn’t work and only 2 wheels out of 4 have brakes. The car has only 55,000 miles! All 2019-2021 Alfa Romeo Stelvios have open recalls about ABS module, but mine is 2018, although the installed ABS is manufactured 2018-2023 (what includes 2019-2021 that have Recalls!). I was driving and almost killed a man who was running across the road because my brakes didn't work!!! I can't drive a car without brakes and feel safe! The problem was indicated by few independent service centers. Alfa Romeo dealer knows about this COMMON issue but doesn’t want to take responsibility for it! I’ve got warning lamps right after my brakes were broken. Not even before! The car was fully serviced on time in the dealership! BRAKE, ESC, AST, P! Also can get an invoice from the repair center if needed!”