2009 BMW M3 problems

“TO WHOM IT MAY CONCERN, I AM VERY HAPPY TO SEE YOUR ORGANIZATION TAKING AN INTEREST IN THIS ISSUE. IT IS A VERY DANGEROUS PROBLEM WITH THIS VEHICLE THAT BMWNA IS WELL AWARE OF, BUT INSISTS THAT IT IS "NORMAL BEHAVIOR" FOR MY CAR/TRANSMISSION. I BROUGHT THE CAR INTO THE DEALER, AND THEY WERE ABLE TO REPRODUCE IT, BUT THEY WERE TOLD BY BMW THAT THIS WAS "NORMAL BEHAVIOR." THE PROBLEM OCCURS WHEN YOU SLOW DOWN- LIKE FOR A TURN, BUT DO NOT COME TO A COMPLETE STOP. THE DCT TRANSMISSION SEEMS TO HAVE TROUBLE FIGURING OUT WHAT GEAR TO SELECT BECAUSE WHEN YOU STEP ON THE GAS TO ACCELERATE, THERE IS A VERY SIGNIFICANT DELAY IN THE ONSET OF POWER- UP TO 2-3 SECONDS. BY THIS TIME, THE DRIVER IS USUALLY REALLY DIGGING INTO THE THROTTLE. THE TRANSMISSION FINALLY PICKS A GEAR, WHICH RESULTS IN THE CAR SUDDENLY LURCHING FORWARD, SOMETIMES INVOKING THE ANTI-SKIP CONTROL. THE DANGER IN THIS BEHAVIOR OCCURS WHEN MAKING A TURN INTO ON-COMING TRAFFIC AFTER SLOWING DOWN TO AROUND 10-15 MPH. AFTER THE TURN, THE CAR IS POSITIONED IN THE TRAFFIC LANE, BUT YOU HAVE NO POWER TO ACCELERATE INTO THE FLOW OF TRAFFIC. THE ONCOMING CARS ARE NOW CLOSING IN ON YOUR CAR AT A FAST RATE, AND…”

“I RECEIVED A RECALL FOR THE AIRBAG ON MY CAR. I CONTACTED BMW TO REPLACE BUT THEY WERE UNABLE TO REPLACE AT THAT TIME. I HAVE TRIED TO CONTACT THEM SINCE TO ARRANGE REPLACEMENT AND THEY HAVE NOT RETURNED MY CALLS.”

“The contact owns a 2009 BMW M3. The contact stated while operating the vehicle, the driver’s and passenger’s side turn signal failed to illuminate. Additionally, the headlights and dashboard lights would flicker on and off. Upon inspection, it was discovered that the electrical wiring insulation was frayed and damaged. The cause of the failure was not yet determined. The manufacturer and local dealer were not notified of the failure. The failure mileage was approximately 84,000.”

“TAKATA RECALL DRIVING MY CAR FOR ABOUT 30 MINUTES ON THE LOCAL STREET AND STOPPED AT A RED LIGHT, LIGHT TURNS GREEN, I TRY TO ACCELERATE AND ENGINE FELT SLUGGISH AND SHUTS OFF. TOWED THE CAR TO MRF ENGINEERING AND CAR NEEDED AN "ENGINE REPLACEMENT" AS MY ROD BEARINGS CAUSED THE ENGINE TO FAIL. COSTED ROUGHLY AROUND $19,000 IN PARTS AND LABOR.”

“S65 V8 ENGINE IN A BMW M3 E90/92/93 AND M5'S WITH A V10 HAS TWO THROTTLE VALVE ACTUATORS THAT FAIL PREMATURELY AT 40-80K MILES. BOTH THE INTERNAL NYLON GEARS AND ELECTRONICS WILL FAIL, AFFECTING ACCELERATOR PEDAL RESPONSE AND CAUSING HESITATION, ESPECIALLY WITH THE DCT TRANSMISSION. THESE PARTS ARE NOT A MAINTENANCE ITEM. WHEN FAILED, THE ENGINE MALFUNCTION, EXCESS EMISSIONS, SKID CONTROL, AND ABS BRAKING WARNING LIGHTS ARE TRIGGERED. ENGINE GOES INTO LIMP MODE. THIS IS DANGEROUS WHEN IT HAPPENS WHILE DRIVING IN RAINY, SNOWY, AND ICY ROAD CONDITIONS. THE THROTTLE VALVE ACTUATOR DESIGN DEFECT SHOULD HAVE TRIGGERED A BMW RECALL. REPLACEMENT PARTS ARE $1000-1300 EACH PLUS $1000 LABOR AND HAVE NEVER BEEN REDESIGNED BY BMW/BOSCH. SO THE REPLACEMENT PARTS ARE ALSO DEFECTIVE AND WILL FAIL PREMATURELY. REPAIRS OCCURRED ON DEC. 2012 AT 80K MILES FOR $2000 AND ON JAN. 2016 AT 140K MILES FOR $3000. A BMW M3 AND M5 RECALL AND REDESIGNED PARTS ARE WARRANTED. BMW TECHNICAL SERVICE BULLETINS SHOULD BE ISSUED FOR THIS DESIGN FLAW. 8YR/80KM FEDERAL EMISSIONS WARRANTY SHOULD COVER THESE REPAIRS AS WELL.”