2004 Chevrolet Corvette fuel system, gasoline problems

“The contact owns a 2004 Chevrolet Corvette. The contact stated while driving approximately 35 MPH, the odor of gasoline was detected by the contact and his wife. The contact stated no warning light was illuminated. The contact stated that the odor of gasoline was strongest in the cabin after refueling the vehicle to a full tank. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that a cross fill tube needed to be installed. The vehicle had been repaired. The contact stated that the gasoline odor was again detected while driving at various speeds. The contact researched online and related the failure to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The manufacturer had not been informed of the failure. The failure mileage was approximately 44,000.”

“The contact owns a 2004 Chevrolet Corvette. The contact stated while driving at slow speeds and approaching a stop, an abnormal odor of fuel was detected. The contact noticed there was fuel leaking in the garage. The vehicle was taken to the local dealer where it was diagnosed that the fuel tank and crossover tube cross connector needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but no additional assistance was provided. The contact stated the failure was related to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The approximate failure mileage was 41,000. The contact stated that the vehicle was repaired and is seeking reimbursement from the manufacturer for the cost.”

“THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED WHILE DRIVING 35 MPH, THE CONTACT SMELLED AN ABNORMAL FUEL ODOR COMING FROM THE ENGINE COMPARTMENT. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL TANK CROSSOVER PIPE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE CONTACT RELATED THE ISSUE TO AN UNKNOWN MANUFACTURER’S RECALL. THE MANUFACTURER WAS INFORMED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.”

“SINCE BUYING THIS CAR AT AUCTION. I NOTICED A FUEL SMELL COMING FROM LEFT REAR WHEELS. I HAVE ASKED THE DEALERSHIP IF THERE WERE ANY RECALLS OR SPECIALS ANNOUNCEMENTS DEALING WITH CAR AND WAS TOLD NO. AFTER READING THE CORVETTE FORUM AND FINDING THERE WAS A REPAIR FOR THE FUEL TANK. NOW MY CAR IS OUT OF THE COVERAGE TIME FRAME AND MILEAGE HOWEVER WITH THE TANK BEING DEFECTIVE SHOULDN'T THEY AT LEAST COVER THE TANK. OR WHAT WAS THE AGREEMENT BETWEEN NHTSA AND CHEVROLET. *TR”

“I FILLED MY TANK TODAY WITH NO OVER FLOW OF GAS. I GOT IN MY VEHICLE AND STARTED THE CAR. I NOW HAVE A VERY STRONG GASOLINE SMELL. IT IS ALL THROUGHOUT THE CABIN AND MAKE GAS APPEARS TO BE RUNNING OUT FASTER THAN NORMAL. I PARK IN A GARAGE WHICH HAS A GAS WATER HEATER IN IT. I AM VERY CONCERNED THAT THE HOUSE COULD CATCH ON FIRE IF THE LEAK GETS STRONGER. *TR”

“NOTICED GAS LEAKING ON GROUND AFTER REFUELING THE CAR....I DON'T DRIVE THE CAR MUCH AND SINCE THEN THERE IS ALWAYS A STRONG SMELL OF GAS. THE CAR NOW HAS 39850 MILES ON IT AND THE SMELL IS GETTING WORSE. *TR”