2006 Chevrolet Corvette exterior lighting problems

“The contact owns a 2006 Chevrolet Corvette. The contact stated while driving at speeds above 25 MPH, the ABS system failed, causing the front brakes to activate without the driver depressing the brake pedal. During the failure the active handling warning light was illuminated. The vehicle was taken to an independent mechanic who diagnosed that the active handling control module wiring harness was faulty and needed to be replaced. Additionally, while operating the vehicle the low beam headlights inadvertently turned off. The mechanic diagnosed that the wiring harness for the exterior lighting needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure. The contact was informed that the vehicle was previously repaired under NHTSA Campaign Number: 14V251000 (Electrical System, Exterior Lighting). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 50,000. The contact stated that he pulled the fuse box and wiring from the car. In the photos, we can see a damaged wire around a tight bend that has created tension and caused a faulty connection.”

“THE FRONT LIGHTS OF THE CAR ONE OF THEM ISN'T WORKING. I BELIEVE THIS ISN'T THE FIRST COMPLAIN ABOUT THIS KIND OF CAR. IT IS DANGEROUS TO BE DRIVING ON THE ROAD. I HAVE TO CONTINUE TO PUT MY HIGH BEAMS ON FOR THEM TO WORK. AT TIMES BOTH THE LIGHTS ARE ON AND WITH TIME DRIVING IT WILL TURN ONE OF THEM OFF. IT'S DANGEROUS BECAUSE THE VISIBILITY ON THE ROAD FOR ME AND OTHER DRIVERS.”

“THE HEADLIGHT COVERS ARE CRAZING OVER WHICH IS MATERIALLY REDUCING THE LIGHT OUTPUT. 1. THE COVERS CANNOT BE POLISHED. NOT ONLY DOES THAT DESTROY THE OUTER COATING, THE CRAZING IS THROUGH-AND-THROUGH. 2. THE COVERS ARE GLUED ON AND CANNOT BE REPLACED BY ANY OFFICIAL MEANS, ALTHOUGH SOME INVENTIVE PEOPLE HAVE MANAGED TO SUCCEED (USUALLY AFTER MULTIPLE FAILED ATTEMPTS) BY STICKING THE ENTIRE ASSEMBLY IN THEIR KITCHEN OVEN. HOWEVER, [SEE NEXT POINT] 3. THE COVERS THEMSELVES ARE NOT AVAILABLE FOR SALE. 4. THE HEADLIGHT ASSEMBLIES THEMSELVES, WHICH COST AROUND $1,000 PER SIDE, ARE SPECIFIC TO THE COLOR OF THE CAR, AND ARE NOW DISCONTINUED. IN OTHER WORDS, THERE IS NO LEGIT PATHWAY TO FIXING THIS PROBLEM. GM MADE A THROWAWAY HEADLAMP ASSEMBLY THAT COST A FORTUNE TO REPLACE WHEN IT WAS PRODUCED, AND NOW IT'S NOT AVAILABLE AT ALL. THIS IS NOT AN OLD CAR. THESE CARS WERE PRODUCED UNTIL 2013. THREE AND A HALF YEARS LATER, YOU CAN'T GET ESSENTIAL PARTS TO MAKE THE HEADLIGHTS SAFE. THOUSANDS OF C6 HEADLAMP COVERS ARE STARTING TO FAIL NOW. THE NHTSA DID A RECALL FOR THE LOW-BEAM WIRING MALFUNCTION ON THIS CAR. THIS IS A SIMILAR PROBLEM IN ITS EFFECT.”

“MY ELECTRONIC STABILITY CONTROL COMES ON REGULARLY ESPECIALLY WHEN I HIT SAND IN DRIVEWAY AND TIRE SPINS WHICH I EXPECT BUT AT OTHER TIMES THE WARNING LIGHT COMES ON WITHOUT ANY TIRE SPIN OR CONDITION THAT WOULD WARRANT THIS. TURNING FROM A STAND STILL IS ANOTHER TIME THE LIGHTS WILL COME ON WITHOUT ANY TIRE SPIN. MY WIFE DRIVES THIS CAR NOW AND I GOT A NEWER ONE. I AM WORRIED ABOUT HER SAFETY AS SHE IS AN OLDER LADY [XXX] AND IF BRAKES LOCKED UP OR STEERING SHE WOULD NOT KNOW HOW TO HANDLE THE SITUATION.”

“TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. WHILE ATTEMPTING TO DRIVE THE VEHICLE AT NIGHT, THE CONTACT BECAME AWARE THAT THE HEADLIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V251000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE EVENING OF THE RECALL REPAIR, THE HEADLIGHTS FAILED TO ILLUMINATE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 133,900.”

“I WAS ON THE INTERSTATE TRAVELING APPROXIMATELY 60MPH WHEN MY LIGHTS WENT OUT. I HAD TO PULL OVER, AND THEIR WAS A GOOD DEAL OF TRAFFIC. I DISCOVERED THAT MY BRIGHT LIGHTS WERE WORKING. I HAD THIS PROBLEM OFF AND ON FOR AWHILE. I TOOK MY CAR IN TO HAVE IT REPAIRED. I GOT IT BACK AND CONTINUED HAVING THE PROBLEM. I HAVE AVOIDED DRIVING AT NIGHT WHICH LIMITS THE USE OF YOUR CAR. MOST PEOPLE WOULD CONSIDER THIS TO BE DANGEROUS AND DEFINITELY A SAFETY ISSUE-DRIVING AND HAVING YOUR LIGHTS GO OUT IN TRAFFIC. *TR”