2006 Chevrolet Corvette problems

“The contact owns a 2006 Chevrolet Corvette. The contact became aware that the VIN was included in NHTSA Campaign Number: 09V491000 (Structure). The vehicle was taken to the local dealer, where the contact was informed that the recall part was no longer available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the part had been discontinued. The contact was advised to purchase the part from a junkyard or to order an entire roof from the dealer at his expense. The contact had not experienced a failure.”

“The contact owns a 2006 Chevrolet Corvette. The contact stated while driving at speeds above 25 MPH, the ABS system failed, causing the front brakes to activate without the driver depressing the brake pedal. During the failure the active handling warning light was illuminated. The vehicle was taken to an independent mechanic who diagnosed that the active handling control module wiring harness was faulty and needed to be replaced. Additionally, while operating the vehicle the low beam headlights inadvertently turned off. The mechanic diagnosed that the wiring harness for the exterior lighting needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure. The contact was informed that the vehicle was previously repaired under NHTSA Campaign Number: 14V251000 (Electrical System, Exterior Lighting). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 50,000. The contact stated that he pulled the fuse box and wiring from the car. In the photos, we can see a damaged wire around a tight bend that has created tension and caused a faulty connection.”

“THE SERVICE ACTIVE HANDLING LIGHT APPEARED AND ALMOST LOST CONTROL OF THE CAR BECAUSE OF A RF BRAKE LOCKING UP. THE CAR WAS GOING ABOUT 40 MPH IN A CITY STREET. *TR”

“2006 Corvette convertible. Has a strong gas smell after filling up. I understand this is a common problem, but Chevrolet will not acknowledge it. The gas can drip down on the hot exhaust system, and start a fire, burning down our house, or out on the road with us in it! Please help us get this deadly problem resolved, with little expense heaped upon us. Thank you, [XXX]”

“We were driving 55 and the car stalled. This has happened several times. Been at dealer and the codes show fine they replaced what they thought was issue and it still does this. Very scary”

“I purchased this car from a dealer in Sarasota Florida. Driving it home from the dealer, I was driving approximately 70 mph on [XXX] near Sarasota. The vehicle suddenly braked and pulled to the left simultaneously. I have taken it to a repair shop that specializes in Corvettes, and trying to ID the problem. In doing research, evidently it is related to the active handling system. There is a recall NHTSA Campaign Number: 10V172000 Manufacturer GENERAL MOTORS CORP. Components STEERING Potential Number of Units Affected 40,028 and a service bulletin 10118.”