NHTSA lists 5 safety recalls and 413 owner complaints for the 2006 Chevrolet Corvette. Most complaints involve structure (65) and exterior lighting (65). The EPA rates it 18–19 mpg combined.
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
GM IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 CHEVROLET CORVETTE PASSENGER CARS MANUFACTURED BETWEEN MARCH 2004 AND JANUARY 2006 EQUIPPED WITH A TILT AND TELESCOPING STEERING COLUMN (RPO N37). IN RARE CASES, REPEATED MOVEMENT OF THE STEERING COLUMN MAY CAUSE A SIGNAL INTERRUPTION WITHIN THE COLUMN. IF THIS OCCURS, THE MESSAGE, "SERVICE ACTIVE HANDLING SYSTEM" WILL APPEAR IN THE DRIVER INFORMATION CENTER, AND ONE OR MORE OF THE BRAKES MAY APPLY, POSSIBLY CAUSING THE VEHICLE TO PULL TO THE RIGHT OR LEFT.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
Complaints for each Corvette model year we’ve synced.
| Model year | NHTSA complaints |
|---|---|
| 1996 | 44 |
| 1997 | 153 |
| 1998 | 399 |
| 1999 | 308 |
| 2000 | 277 |
| 2001 | 203 |
| 2002 | 170 |
| 2003 | 112 |
| 2004 | 217 |
| 2005 | 538 |
| 2006 | 413 |
| 2007 | 386 |
| 2008 | 589 |
| 2009 | 152 |
| 2010 | 84 |
| 2011 | 85 |
| 2012 | 56 |
| 2013 | 82 |
| 2014 | 64 |
| 2015 | 65 |
| 2016 | 105 |
| 2017 | 257 |
| 2018 | 51 |
| 2019 | 148 |
| 2020 | 34 |
| 2021 | 13 |
| 2022 | 21 |
| 2023 | 27 |
| 2024 | 22 |
| 2025 | 11 |
| 2026 | 1 |
“The contact owns a 2006 Chevrolet Corvette. The contact became aware that the VIN was included in NHTSA Campaign Number: 09V491000 (Structure). The vehicle was taken to the local dealer, where the contact was informed that the recall part was no longer available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the part had been discontinued. The contact was advised to purchase the part from a junkyard or to order an entire roof from the dealer at his expense. The contact had not experienced a failure.”
“The contact owns a 2006 Chevrolet Corvette. The contact stated while driving at speeds above 25 MPH, the ABS system failed, causing the front brakes to activate without the driver depressing the brake pedal. During the failure the active handling warning light was illuminated. The vehicle was taken to an independent mechanic who diagnosed that the active handling control module wiring harness was faulty and needed to be replaced. Additionally, while operating the vehicle the low beam headlights inadvertently turned off. The mechanic diagnosed that the wiring harness for the exterior lighting needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure. The contact was informed that the vehicle was previously repaired under NHTSA Campaign Number: 14V251000 (Electrical System, Exterior Lighting). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 50,000. The contact stated that he pulled the fuse box and wiring from the car. In the photos, we can see a damaged wire around a tight bend that has created tension and caused a faulty connection.”
“THE SERVICE ACTIVE HANDLING LIGHT APPEARED AND ALMOST LOST CONTROL OF THE CAR BECAUSE OF A RF BRAKE LOCKING UP. THE CAR WAS GOING ABOUT 40 MPH IN A CITY STREET. *TR”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Corvette Auto (S6), 8 cyl, 6.0 L · Rear-Wheel Drive | 15 | 25 | 19 | $4,050 | 468 |
| Corvette Man 6-spd, 8 cyl, 6.0 L · Rear-Wheel Drive | 16 | 26 | 19 | $4,050 | 468 |
| Corvette Man 6-spd, 8 cyl, 7.0 L · Rear-Wheel Drive | 15 | 24 | 18 | $4,300 | 494 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
5 safety recalls as of Nov 10, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 413 complaints with NHTSA. The most-cited components are structure (65), exterior lighting (65), electronic stability control (esc) (52). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2006 Chevrolet Corvette at 18–19 mpg combined, depending on engine and drivetrain (3 versions rated).