2005 Chevrolet Malibu steering problems

“The contact owns a 2005 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the steering wheel became inoperable. There was no warning light illuminated. The contact stated that the failure was related to the U-joint in the steering column, which made the vehicle difficult to control. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.”

“Power steering failing. As I was driving down the road I got a power steering message and chime. No dash light came on and I lost all ability to turn my vehicles steering wheel. I went to add power steering fluid just to learn that my 2005 Chevy Malibu maxx LS comes equipped with EPS(electric power steering). Then I check on NHTSA for safety recalls and there is a safety recall for the Chevy Malibu maxx including the 2005 Chevy Malibu maxx. I was pulling safely out of store parking lot into traffic and I had to hit the ditch luckily I didn't get T-boned. Thanks to my reaction time being fast I made it safely outta the road. I am available to have car inspected if needed. It just started on 11/23/2025 I bought the car used a year prior in Nov. 2024.”

“The steering locked up when the brakes were pressed and the steering wheel was turned to avoid crashing with another car. The result is the crash happened and damage to both cars. Thankfully traffic was only going around 10 mph. If this had happened at high speed my son may have been seriously injured or even killed. The mechanic is working on it now and has reported the power steering module and power steering motor has to be replaced.”

“The car has a recall for power steering the recall covers the torque sensor in the steering assembly I had the recall done about 6-8 weeks ago & now I’m dealing with another power steering issue I took the car to Chevy & the whole power steering motor has failed they say it is not covered under the recall although it should be other Malibu models are this is very frustrating & unacceptable as I just got a recall for steering done & now I can’t even drive my car”

“The EPS began sporadically and severely jerking the steering very powerfully while driving and stationary and draining the battery at an accelerated rate necessitating multiple replacements of and charging 2 batteries to get to and from my job and anywhere else making everyday life very difficult beginning in early 2024. A couple months before this issue became a daily and constant occurrence in in February 2024 between the 6th and 13th I had a stabilizer link and control arm on the right side replaced and an alignment done at Firestone, on the document for the alignment it states no manufacturers recommended services necessary on suspension. The mechanic who replaced the parts told me that the EPS issue is a likely cause for the steering system damage as a vehicle is not meant to remain stationary while the wheels are forcibly turned as is the case when the EPS takes over and jerks the wheel often to the extremes of its function. I have video of this on multiple occasions and it can be inspected still occuring. I took it to Hendrick Chevrolet Shawnee Mission in April 2024 and explained the services done recently and the mechanics opinion on the EPS. They held…”

“The contact owns a 2005 Chevrolet Malibu. The contact stated that while driving at 60-70 MPH, the steering wheel turned to left and to the right independently. The traction control warning light was illuminated. An unknown local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 220,000.”