2021 Chevrolet Silverado fuel/propulsion system problems

“On my way home to [XXX] from [XXX] around XXX, my 2021 Chevy Silverado with 84,xxx miles with the 6.2 L engine started to make a popping sound. I checked my dash for any error codes and there were none. The oil pressure, temp, and transmission temp gauges all read normal. I stopped and topped the gas tank off with premium gas and checked the oil level, which was good. I was able to limp the truck back to my house. The next morning when I started it, there were error codes and the engine was still making the popping noise as well as a louder knocking noise. I started researching the symptoms, called two local independent shops and concluded the DFM system that shuts cylinders off to conserve gas has failed and caused the lifters to fail. I was told the failed lifter could and probably did damage the cam shaft(s). If I kept driving it, the camshaft damage could cause complete engine failure and more safety consequences. One shop quoted $5000 to replace lifters and $8000 if the camshafts were damaged. The other shop was similar, but offered a rebuilt engine for $12,000 because the lifters, camshafts, and new GM crate engine were all back ordered with no ETA from…”

“I was traveling on a 55mph road. My Chevy Silverado started to shake and lose propulsion. I pulled off on the side of the road. In idle it shook. The dealership was one mile to my south. I turned on the hazard lights and went to the dealership. I could only get the vehicle to 45mph as in shook very bad the whole way. It felt as if the engine was going to explode the whole way there. The vehicle was taken to the dealership where it has been initially diagnosed as a bad lifter.”

“I am submitting this complaint regarding a 2021 Chevrolet Silverado 1500 Trail Boss 4WD with the [6.2L V8 (L87)], VIN [XXX], 101,000 miles. The truck was assembled in Mexico in XXX, about six weeks before XXX, just outside the build range of GM recall 25V-274 (N252494000, Engine Failure). On 10/2/2026, [XXX], [XXX] a certified GM dealership, diagnosed crankshaft and lifter failure, matching the recall condition. Codes: P0300, P050D, P0016. The truck was shaking violently, the ESC and emergency braking system failed, reducing engine power. GM's Part 573 filing attributes the defect to out-of-specification crankshafts and identifies a Mexico-based crankshaft supplier. I ask GM to confirm my engine's build date and crankshaft source. A six-week gap in build date should not exclude a truck with the same failure. Engine failure can cause sudden loss of power while driving, a safety risk. The dealer quoted repairs of up to $10,292.00. I request: That GM cover the repair in full as a goodwill adjustment. That GM and NHTSA review expanding the recall population to trucks built near my date.”

“My 2021 Chevrolet Silverado 1500 RST with the 6.2L engine experienced an engine seizure. The engine was replaced by a Chevrolet dealership under a GM safety recall. Immediately after picking up the vehicle following the recall engine replacement, the truck stalled while still in the Chevrolet dealership parking lot. There was no warning before this first stall. We continued our trip because we did not realize at the time that the stall could indicate a problem following the engine replacement. During the drive from [XXX] to [XXX], the problem continued. In [XXX], the check engine light illuminated and the truck began malfunctioning. The vehicle subsequently stalled again. The problem continued after returning to [XXX]. A Chevrolet dealership in [XXX] inspected the vehicle and reproduced/confirmed a problem involving the camshaft position sensor wiring/connector. The dealership demonstrated the problem by manipulating the connector/wiring and recorded a video of the diagnostic procedure. The vehicle is currently at the Chevrolet dealership and is available for inspection. The affected component should also be available for inspection because it has not yet been…”

“On August 22, 2025 the malfunction indicator lamp (code: P146B Evap. purge pump) illuminated with no noticeable change. Ran codes at auto zone which stated engine failed and emissions not ready. August 25, 2025 drove to certified Chevy dealer dropped off vehicle and showed the service advisor the fix finder test results from auto zone as well as the illuminated indicator lamp (check engine light). August 26, 2025 picked up my vehicle with receipt stating "found dtc's P146b and P1467 stored in ECM (engine control module) for evap purge pump fault. inspected evap canister for any signs of fuel and none were found. replaced evap purge pump per special policy #N232395310. Cleared dtc and road tested vehicle to verify repair". September 9, 2025 my engine indicator light illuminated and my engine entered limp mode, a safety feature which reduces cylinder output/capacity. September 12, 2025 while in limp mode, I returned to the service dealer and informed them of the reduced power (limp mode) and my confusion as the second engine symbol that has been illuminated is in a different area than the first and my truck has ONE engine. (editor note: malfunction indicator lamp…”

“2021 Chevrolet Silverado 1500 Custom 2.7 L Turbo 4 cylinder with 34,000 miles When Truck cranks and put in gear begins moving at low speed between 1-2 gear (low speed 5-10 mph forward and also in put into reverse) hard jolted severely injuring passenger. Felt like being rear-ended by another car. Passenger was hurt & required Trauma 1 EMS & 2 surgeries (Spinal Fusion Surgery) hospitalization from 12/2/2025 to 12/13/2025. The truck jolt directly caused this accident and there were many recalls for this truck yet we had no direct knowledge of this information & was never notified of any of these issues. Truck was services at same dealership just weeks prior to accident. The truck check engine light came on only after the accident. It happened on a private gated property. Only select trucks have been said to do this very hard jolted injuring passenger and owners are not made aware using Silverado 1500 trucks. Please acknowledge receipt of this report and advise. Thank you.”