2021 Chevrolet Silverado power train problems

“The lifter on my cylinder one is failing. This is a known issue with the Chevrolet 5.3L 8cylinder engine and 2021 models are known for being notoriously bad with lifter issues. My safety and the safety of other drivers that own 2021 Chevrolet models is impacted due to this issue can cause the engine to completely fail and shut off while driving which could cause severe injuries up to death. The problem is a widespread issue and mine was confirmed by an independent service mechanic. The vehicle is now being inspected by the dealership. The issue did not arise until I reached 104,000 miles.”

“2021 Silverado with 5.3 engine/8spd transmission/38,000 miles just outside of the 5-year powertrain warranty *No current recalls under this VIN as of 10/07/2026* Undiagnosed issues with symptoms similar to transmission or rear end slippage, torque converter or clutch pack problems. No warning lights or messages have appeared 1) Vehicle seems to hunt for proper gearing between 30-40 mph (3rd to 4th gear) with light shuddering before shifting gears. Occurred 20+ times 2) Sudden jerk when taking off from dead stop. Feels like being lightly bumped from behind then drives normally. Occurred 4 times 3) Only noticed when towing appx 6,000lb trailer descending down a hill - A one-time loud clunk when easing off throttle and coasting downhill. The sound is similar to hitting a metal desk with a fist. Occurred 7 times. Spoke with local Chevrolet dealer who informed me the powertrain warranty has recently expired, and no repair cost would be covered. Recommended dealer service would be to replace the transmission fluid and filter with Mobil 1, potentially reprogram the transmission, and replace the torque converter. All on a vehicle with only 38,000 miles”

“I am submitting this complaint regarding a 2021 Chevrolet Silverado 1500 Trail Boss 4WD with the [6.2L V8 (L87)], VIN [XXX], 101,000 miles. The truck was assembled in Mexico in XXX, about six weeks before XXX, just outside the build range of GM recall 25V-274 (N252494000, Engine Failure). On 10/2/2026, [XXX], [XXX] a certified GM dealership, diagnosed crankshaft and lifter failure, matching the recall condition. Codes: P0300, P050D, P0016. The truck was shaking violently, the ESC and emergency braking system failed, reducing engine power. GM's Part 573 filing attributes the defect to out-of-specification crankshafts and identifies a Mexico-based crankshaft supplier. I ask GM to confirm my engine's build date and crankshaft source. A six-week gap in build date should not exclude a truck with the same failure. Engine failure can cause sudden loss of power while driving, a safety risk. The dealer quoted repairs of up to $10,292.00. I request: That GM cover the repair in full as a goodwill adjustment. That GM and NHTSA review expanding the recall population to trucks built near my date.”

“The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that the vehicle previously had a bell housing installed to catch internal metal shavings; however, the housing assembly failed again and needed to be replaced. The vehicle was taken to a dealer for a diagnostic test. The contact associated the failure with the torque converter. The torque converter was previously replaced once. The contact stated that while driving, the vehicle felt like it was driving over rumble strips or speed bumps, which the contact felt and heard. The manufacturer was notified of the failure. The dealer was unable to duplicate the failure. The failure mileage was 60,000.”

“This vehicle's engine failed on a high-volume roadway in [XXX] which resulted in a significant safety issue. The vehicle was taken to a certified Chevrolet dealership in Scottsdale (Van Chevrolet) whereby the engine in this 5.3L V8 was replaced due to catastrophic engine failure with the lifters being the suspected cause of the failure. Aside from the $10,400 cost of the remanufactured engine replacement, I have had considerable discussions (live and written) with GM Arizona and Corporate representatives outlining the issue(s) and filing formal complaints. These have gone relatively unheeded... Unfortunately, this is the second 5.3L V8 engine failure in one of our GM vehicles as I will be filing yet another formal complaint under separate cover for a 2021 Tahoe 5.3L V8 which had an engine failure requiring new lifters. I am not done yet as I have an appointment tomorrow for what appears to be, a third Chevrolet vehicle with a 5.3L V8 engine lifter failure. Depending on the outcome of this service appointment, I may be filing a third safety complaint regarding the GM 5.3L V8 engine. In my opinion, the NHTSA should absolutely open an investigation into this…”

“Vehicle has a bad valve body which was confirmed by the dealer. Driving down the street and the engine went from 3 to 4 gear and the rear wheels locked up. Also when coming to a stop the truck jerks so bad it snaps your neck. GM has major problems with these trucks and knows the problems and keeps issuing bulletins however they have a massive backlog of orders for parts to fix these trucks which leaves people's trucks sitting at service centers for months waiting for backordered parts”