NHTSA lists 11 safety recalls and 174 owner complaints for the 1996 Chrysler Cirrus. Most complaints involve engine and engine cooling (40) and power train (23). The EPA rates it 21 mpg combined.
FEDERAL-MOGUL IS RECALLING CERTAIN REPLACEMENT CONTROL ARM ASSEMBLIES, PART NUMBERS K7425, 10945, FA4510X, K7427, 10946, AND FA4611X, SOLD FOR USE ON VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE BALL JOINT ON THE CONTROL ARM ASSEMBLY CAN FAIL CAUSING THE BALL STUD TO WEAR THROUGH THE CONTROL ARM HOUSING RESULTING IN NOISE AND/OR SEPARATION OF THE BALL STUD FROM THE HOUSING.
QUALIS AUTOMOTIVE IS RECALLING CERTAIN AFTERMARKET BALL JOINTS SOLD FOR USE ON CERTAIN PASSENGER VEHICLES. THE SOCKET MAY HAVE BEEN EXCESSIVELY HARDENED WHICH COULD CAUSE IT TO CRACK NEAR THE RETAINING RING GROOVE ALLOWING THE BALL STUD TO SEPARATE UNDER IMPACT LOAD. THE SUBJECT BALL JOINTS WERE SOLD AS FOUR PART NUMBERS, D10945, D10946, G10945, AND G10946. THE AFFECTED CONTROL ARMS, D10945 AND D10946, ARE STAMPED WITH THE FOLLOWING DATES ON THE BALL JOINTS: 134308, 135708, 100109, 102709, 104109, 105509, 107609, 108909, 110309, 113209, AND 116609. THE G10945 AND G10946 ARE THE SAME PART AS THE D10945 AND D10946 RESPECTIVELY. THEY ARE LABELED DIFFERENTLY DEPENDING ON THE AFTERMARKET CUSTOMER.
CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“TL* THE CONTACT OWNS A 1996 CHRYSLER CIRRUS. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THERE WAS SMOKE SEEN FROM THE ENGINE COMPARTMENT. THE CONTACT ALSO NOTICED THAT THERE WAS OIL LEAKING ONTO THE GROUND. THE FIRE WAS EXTINGUISHED USING A FIRE EXTINGUISHER. THE DEALER WAS CONTACTED AND THEY ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 96V006000 (ENGINE AND ENGINE COOLING:ENGINE:GASOLINE). THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 49,063.”
“MY 1996 CIRRUS WITH ONLY 87+++ MILES SUDDENLY DOWNSHIFTS WHILE DRIVING OVER 40 MPH. THIS IS A RECENT PURCHASE. I LIVE IN WYOMING AND IT IS WINTER TIME WITH ICY ROAD CONDITIONS NEARLY EVERYWHERE. I AM A SINGLE MOTHER WITH A 10 YEAR OLD DAUGHTER. WHEN THIS HAPPENED TO US ON THE HIGHWAY, IT CAUSED US TO SPIN OFF OF THE ROAD. LUCKILY WE WERE UNHURT. THIS AUTOMOBILE IS UNSAFE!!! THE LIMP MODE APPEARS TO BE ACTIVATED DUE TO FAULTY/LOW QUALITY PARTS BY CHRYSLER. WHY ISN"T THIS RECALLED??? I HAVE NO CHOICE BUT TO DRIVE THIS CAR. I WILL SUE CHRYSLER IF WE HAVE ANOTHER INCIDENT!!! THIS INCIDENT OCCURED WHEN WE WERE DRIVING STRAIGHT AT ABOUT 50 MPH.”
“AFTER HAVING THE FRONT BRAKE PADS REPLACED EMERGENCY BRAKE LOCKED AND MELTED THE BRAKE DRUM WITHOUT BEING ENGAGED. WHILE DRIVING A PASSING MOTORIST NOTICED FIRE COMING FROM THE REAR OF THE VEHICLE AND NOTIFIED THE CONSUMER. EMERGENCY BRAKING SYSTEM AND DRUMS HAD TO BE REPLACED. THE CAUSE OF THE FAILURE WAS UNDETERMINED. *AK”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Cirrus Auto 4-spd, 4 cyl, 2.4 L · Front-Wheel Drive | 18 | 26 | 21 | $2,950 | 423 |
| Cirrus Auto 4-spd, 6 cyl, 2.5 L · Front-Wheel Drive | 18 | 26 | 21 | $2,950 | 423 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
11 safety recalls as of Nov 10, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 174 complaints with NHTSA. The most-cited components are engine and engine cooling (40), power train (23), service brakes, hydraulic (23). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 1996 Chrysler Cirrus at 21 mpg combined, depending on engine and drivetrain (2 versions rated).