2022 Ford Bronco Sport electrical system problems

“Water is entering the vehicle and dripping onto the interior floorboards, particularly when the air conditioning is running.This has caused growth of mold and rust inside the vehicle. The vehicle has developed multiple dashboard warning lights, and the turn signals and windshield wipers have stopped functioning. Most concerning, the steering wheel has locked while the vehicle was in motion, leaving me unable to steer even though the engine remained running.This created a serious and immediate safety hazard. The vehicle has since become inoperable and will no longer start. The source of the water intrusion and the underlying causes of the electrical and steering failures have not been confirmed. However, the combination of water entering the vehicle, multiple warning lights, loss of turn signals and windshield wiper operation, loss of steering control while the engine remained running, and the subsequent failure to start raises serious concerns about the vehicle’s safety and possible electrical system damage. I took the vehicle in for an inspection to determine the cause of these problems\. I was informed that diagnostic testing would cost approximately $250 per…”

“after the dealership executed Safety Recall 25S76, the vehicle immediately began violently sputtering and surging on public roads, and the service department actively concealed the resulting diagnostic fault codes.”

“My 2022 Ford Bronco Sport exhibits severe engine knocking and low fuel pressure, which are primary symptoms of open safety recalls 24S16 and 25S76. On 9/29/26, Seelye Ford of Kalamazoo charged me $220.21 out-of-pocket for a powertrain recall system software update. They are now refusing to inspect the physical fuel injectors or complete the safety recalls unless I pay out-of-pocket to replace an unrelated push-to-start button module, holding a federal safety recall hostage. The vehicle continues to malfunction identically after their software flash, making it a severe stalling and fire hazard. It is currently stranded on the dealer's lot.”

“My 2022 Bronco Sport suffered a physical underhood engine fire due to Recall 25S76 / Campaign 25V467. Ford Corporate is refusing to provide a loaner vehicle or alternative transportation, leaving me stranded while the vehicle sits unrepairable at a Ford dealership awaiting a final hardware remedy that does not yet exist. We have also been denied the Ford Buy Back program even though we COULDNT and were BLOCKED to set a maintenance appointment for said recall to attempt to prevent this from happening because they do not have a permanent fix. The dealership and Progressive insurance want to replace all burnt parts with the same defective recalled parts which should be illegal and is unsafe. We just want the means to get our family into a safe vehicle.”

“I am reporting a safety concern involving the transmission in my 2022 Ford Bronco Sport equipped with the 1.5L engine and 8-speed automatic transmission (8F35). I purchased this vehicle new in May 2022 with approximately 6 miles on it. At approximately 83,000 miles, the vehicle displayed a “Powertrain Malfunction/Reduced Power” warning through FordPass. The notification stated that a transmission clutch had not applied within the expected amount of time and warned that I may experience limited functionality, including unavailable gears. I took the vehicle to an authorized Ford dealership, All Star Ford Denham Springs, for diagnosis. On August 4, 2026, the dealership informed me in writing that the vehicle has an internal transmission failure and metal in the transmission fluid. The technician determined that the transmission requires complete replacement. I was subsequently quoted approximately $13,000 for the repair. I am concerned that an internal transmission failure of this nature could result in reduced propulsion, unavailable gears, abnormal shifting, or loss of vehicle mobility, particularly if the failure occurs while the vehicle is being driven. Thus…”

“I've had a Blindspot warning light alert, told by dealership this is an electrical issue, after a web search, I see this is a common and known issue for Ford, yet no recall has been issued. I also have another know, common powertrain issue with my rear differential. The vehicle makes noise when turning, unstable when driving. The vehicle is less than 5yrs old and under 60k miles. Both issues are safety issues and could cause an electrical fires or vehicle stalling. I am scheduled for a 2nd inspection on 7/31 and hopefully repair.”