NHTSA lists 8 safety recalls and 115 owner complaints for the 2024 Ford Bronco Sport. Most complaints involve engine (27) and electrical system (27). The EPA rates it 23–26 mpg combined, and NHTSA gives it 5 stars overall.
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“The vehicle shut off and lost power while I was driving this July. It happened while I was in the turning lane, about to turn onto the interstate. There were no warning lights on the dashboard, so I had no indication of an issue or any forewarning that the vehicle would shut off. When it shut off, it then restart but would not allow me to use the gas. The engine and battery light came on. Had I made it onto the highway and had the vehicle shut off, the situation could have been significantly more dangerous. Luckily the cars behind me were paying attention and able to swerve around my sporadic spot without any warning from a brake light. I had the vehicle towed to Ford for repair. They said it was an issue with the fuel tank sensor and they repaired it. The exact same thing happened again, less than two months later in early September, this time while I was in the middle of a busy intersection. Again the car behind me slammed on his brakes and I flipped on my hazards and inched slowly to a safe spot. The same lights came on, but when I turned the car off and back on, all the lights were off. Ford replaced the fuel line, but they haven’t been able to find what…”
“I purchased a new 2024 Ford Bronco Sport on XXX from Sayville Ford in [XXX]. They failed to disclose an unremedied safety recall (24V-267) on the vehicle that was issued on XXX and still sold me the vehicle. When I went back to them after seeing that there was a recall on the car, they denied the existence of the recall despite me showing them the recall notice on both the NHTSA and Ford websites. Last year there was another safety recall for leaking fuel injectors (25V-467) that I brought my car in for service, and they claimed to have done a software fix. Upon checking the recall checked on the NHTSA website (6 months after service) it lists that the safety recall work was never performed, despite the dealership keeping my car for the entire day and telling me the work was performed. This dealership has been evasive and deceptive when I have confronted them about these issues and should be examined and fined for their practices.”
“On Sunday XXX I left my property at [XXX] and at the first stop sign, I braked but the vehicle accelerated causing me to jam the breaks and the engine immediately died. After restarting, and in drive at the stop sign, the vehicle accelerated on its own with my foot on the break, I jammed the breaks and the engine again quit. In this fashion, I returned the vehicle to my property and then had it towed to Palm Coast Ford: [XXX], s [XXX]. When loading the vehicle for towing, the vehicle even though “in neutral” as indicated on the dash, was in gear also causing a safety issue for the tow driver and myself. Note – this vehicle will not shift to neutral unless the vehicle’s engine is on. This situation was extremely dangerous and put myself and others in harm’s way. A vehicle under any circumstances should not “self-accelerate” not the engine die while in operation. A precursory review by Palm Coast Ford technicians suggested a fault with the transmission’s torque convertor preventing the vehicle shifting to neutral.”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Bronco Sport 4WD Auto 8-spd, 3 cyl, 1.5 L, Turbo · All-Wheel Drive | 25 | 29 | 26 | $2,450 | 342 |
| Bronco Sport 4WD Auto (S8), 4 cyl, 2.0 L, Turbo · Part-time 4-Wheel Drive | 21 | 26 | 23 | $2,800 | 386 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
8 safety recalls as of Oct 27, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 115 complaints with NHTSA. The most-cited components are engine (27), electrical system (27), power train (23). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2024 Ford Bronco Sport at 23–26 mpg combined, depending on engine and drivetrain (2 versions rated).
NHTSA's New Car Assessment Program gives the 2024 Ford Bronco Sport 5 out of 5 stars overall.