2015 Ford Escape engine and engine cooling problems

“The contact owns a 2015 Ford Escape SE. The contact stated that while idle at a stop light with the left-turn signal on, the vehicle started to jerk, and loud noises were coming from the front end of the vehicle. The Check Engine light illuminated, and the vehicle failed to move. The Fire Department arrived and assisted the contact with pushing the vehicle to the side of the road. The vehicle was towed to a certified mechanic at Precision Auto Shop, who diagnosed that the coolant was leaking. After further inspection, the dealer also diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure, and a claim was filed. The failure mileage was approximately 111,400.”

“The contact owns a 2015 Ford Escape. The contact received notification of NHTSA Campaign: 25V695000 (Back Over Prevention); however, the part to do the recall repair was not available. The contact stated that occasionally, while shifted in reverse, the rearview camera failed to display as intended and was possibly impacted by severe weather conditions. No warning light was illuminated. In addition, the contact stated that during colder weather, the heater failed to operate as intended while activated. After further inspection, the coolant reservoir was abnormally low. The vehicle was taken to a local dealer, where it was determined that the coolant level was extremely low. The coolant reservoir was refilled; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.”

“The contact owns a 2015 Ford Escape. The contact stated that while driving approximately 45-50 MPH, the engine was overheating. Upon inspection, the contact noticed that the coolant level was significantly low. The contact added coolant to the coolant reservoir. Additionally, the contact noticed that coolant was leaking onto the ground. The vehicle was taken to an independent mechanic, where a coolant line was replaced; however, the failure persisted. The check engine warning light was illuminated. Additionally, the contact stated that the failure had caused collateral damage to the vehicle. The contact stated that the transmission, the serpentine belt, and the pulley were replaced. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 150,000.”

“The contact owns a 2015 Ford Escape. The contact stated that the check engine warning light was illuminated. The contact stated that upon scanning the vehicle with a vehicle scanner, the contact retrieved diagnostic trouble codes indicating an engine misfire. The contact replaced the ignition coils; however, the failure persisted. The contact stated that while replacing the spark plugs, the spark plug thread of cylinder #4 remained stuck in the cylinder head. The vehicle was taken to an independent mechanic, where the contact was informed that the spark plug thread might be stuck because the cylinder head had melted around the spark plug thread. The mechanic determined that the cylinder head needed to be replaced. The dealer was notified of the failure and recommended the cylinder head replacement. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in an undisclosed recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 80,000.”

“The contact owns a 2015 Ford Escape. The contact stated while idling and while driving at various speeds, there was a significant amount of smoke coming out of the exhaust pipe. There was no warning light illuminated. The vehicle was taken to A1 Auto 3 Brothers Car Repair, where it was diagnosed that the engine had failed due to piston rings failure, and the turbo charger also failed. The dealer determined that the engine and the turbo charger needed to be replaced. The warranty company informed the contact that only the turbo charger was covered under warranty. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure. The failure mileage was approximately 96,000.”

“The contact owns a 2015 Ford Escape. The contact stated that on several occasions while driving at high speeds, there was smoke coming from the engine compartment and from the exhaust pipes. The check engine warning light was illuminated. The contact used a handheld scanner to retrieve DTC: P1299 (Cylinder Head Temperature Sensor Detected Engine Overheating Condition). The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 200,000.”