2000 Ford Expedition steering problems

“The contact owns a 2000 Ford Expedition. The contact stated while driving 30 MPH, the contact became aware that the electronic power steering was not functioning properly, requiring increased effort to prevent oversteering. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the steering shaft. The vehicle was repaired, but the failure reoccurred because the aftermarket replacement part was too short. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 315,000.”

“I WAS DRIVING THE DOWN THE STREET GOING TO WAL-MART ON PENDLETON PIKE IN INDIANAPOLIS INDIANA THE CAR SHIFTED FROM DRIVE TO NEUTRAL ON ITS OWN. I SHIFTED IT BACK IN GEAR DROVE ON TO WAL-MART THEN TO WENT TO ALDIS. WHEN I CAME OUT OF ALDIS ALSO ON PENDLETON PIKE THE CAR WOULDN'T COME OUT OF PARK WITHOUT KEY BEING IN ACC POSITION FOOT ON BRAKE AND PLAYING WITH GEARSHIT FOR APPROX 15 MINS IT WAS LOCKED. THEN THE POWER WINDOWS ALSO WENT OUT IN THE SAME TIME THAT THIS ALL HAPPENED. NOW MY CAR WILL NOT GO INTO GEAR WITHOUT MESSING WITH GEARSHIFT FOR SEVERAL MINUTES AND MESSING WITH IGNITION SWITCH MUTIPLE TIMES BEFORE I CAN GET CAR INTO MOTION.”

“TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, AN ABNORMAL BANGING NOISE WAS HEARD FROM UNDER THE FRONT END OF THE VEHICLE BEFORE THE STEERING WHEEL SUDDENLY FAILED. THE CONTACT STATED THAT THE VEHICLE SUDDENLY VEERED INTO THE RIGHT LANE AND NEARLY CRASHED INTO ANOTHER VEHICLE. THE CONTACT MOVED TO THE SHOULDER TO INSPECT THE VEHICLE AND DISCOVERED THAT THE FRONT DRIVE SHAFT WAS FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS ADVISED THAT THE FAILURE OF THE DRIVE SHAFT ALSO CAUSED DAMAGE TO THE TRANSFER CASE, SHAFT LINKAGE AND OXYGEN SENSORS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT NO SOLUTION WAS OFFERED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 196,000.”

“2000 FORD EXPEDITION, WHILE DRIVING STEERING WENT OUT. *BF THE DRIVER LOST CONTROL OF THE VEHICLE AND STRUCK A CEMENT WALL. OHIO TRAFFIC REPORT # 10-0688-91. *JB UPDATED 04/14/10 *BF”

“DRIVING ON 4 LANE TWISTY PARKWAY, THE LEFT TIE ROD BROKE WITHOUT ANY WARNING, LOST ALL STEERING CONTROL, APPLIED BRAKE AND TRIED TO CONTROL VEHICLE, TOOK ABOUT 200 YARDS TO COME TO A STOP. FORTUNATELY I WAS ABLE TO AVOID A CRASH, HAD VEHICLE TOWED TO DEALER WHERE CAR IS ALWAYS SERVICED AND MAINTAINED, AND REPLACED ALL 4 TIE RODS. *NM”

“IN EARLY JAN 2006, WE HAVE A POPPING SOUND AND MOVEMENT IN THE STEERING WHEEL OF OUR 2000 EXPEDITION. WE COULD FEEL IT MOVING IN THE STEERING WHEN DRIVING AND WERE CONCERNED. WE HAVE AN EXTENDED WARRANTY ON OUR EXPEDITION SO WE TOOK IT TO GERMAIN FORD IN COLUMBUS, OHIO. THEY SAID THE LEFT FRONT STABILIZER LINK BOLT HAD BROKE IN HALF AND THE STABILIZER BAR WAS SLIPPING ON AND OFF CAUSING THE MOVEMENT AND SOUND. THEY TOLD ME THIS WAS NOT A WARRANTY ITEM. MY EXPEDITION HAS ONLY 51,000 MILES AND IS DRIVEN BY MY WIFE TO WORK. AT THE SAME TIME THE DEALER TOLD ME BY BALL JOINTS NEEDED TO BE REPLACED. I SAID HOW CAN A STEEL BOLT IN THE STEERING LINKAGE ACTUALLY BRAKE AND NOT BE COVERED? I ASKED FOR THE SERVICE MGR AND HE ACTUALLY SAID TO ME "THEY DON'T MAKE THINGS LIKE THEY USE TO". I THEN RECALLED A SERVICE NOTICE SOME TIME BACK ABOUT SOMETHING IN THE FRONT END OF EXPEDITIONS SO I LOOKED THROUGH MY FILES. SURE ENOUGH, FORD SENT OUT A SERVICE BULLETIN IN 6-04 "TITLED TIE ROD INSPECTION PROCEDURE". WHILE THE SERVICE BULLETIN COVERS A COUPLE ITEMS IT BELIEVE IT SHOWS FORD KNEW THEY HAD A PROBLEM WITH THE FRONT ENDS AND SENT OUT A SERVICE NOTICE TO EXCUSE THEMSELVES AND…”