146 owner complaints to NHTSA about the 1996 Ford Explorer cite vehicle speed control, 10% of all 1,468 complaints for this model year. NHTSA also lists 2 recalls on this component.
“WHILE DRIVING IN "D" IN FIRST TO SECOND IT HAS HAD A PROBLEM SHIFTING BETWEEN THE 1ST AND 2ND GEARS WHEN ACCELERATING AND WILL REV HIGH RPMS AND SOMETIMES DO ABSOLUTLEY NOTHING WHEN DRYING TO MOVE FORWARD UNLESS I DE ACCELERATE AND THEN TRY TO ACCELERATE AGINE THEN FINALLY IT WILL CATCH AND GO IN TO 2ND AND PROCEED TO 3RD AND THEN 4TH AND THEN 5TH ,4TH AND 5TH WHEN ACCELERATING SOUNDS VERY ROUGH WHEN ACCELERATING LIKE IT'S TRYING TO HARD TO DRIVE, LATELY IT JUST THE OTHER DAY I HAD TROUBLE GETTING IT TO GO IN TO D TO 1ST 2ND 3RD AUTOMATIC TRANSMISSION SHIFTING WAS NOT WANTING TO CATCH HAD T OK TRY 3-6 TIMES DE ACCELERATING AND ACCELERATING TO TRY TO GET IT TO GO FINALT IT CAUGHT AND I WAS ABLE TO DRIVE IT SO I STOPPED AT THE PARTS STORE HAD THEM DO A SCAN AND THE ONLY CODE THAT CAME UP WAS P1701 THEY LOOKED IT UP AND IT SAID SOMETHING TO DO WITH TROUBLE IN REVERSE WITCH IN REVERSE HAS NO PROBLEM AT ALL SO I'M A LITTLE CONFUSED ABOUT IT AND ALSO A LITTLE SCARED TO DRIVE IT WHEN THIS IS MY ONLY TRANSPORTATION AND IF IT WON'T ENGAGE IN TO GEAR WHEN ACCELERATING WHEN IN D THAT COULD BE POTENTIALLY DANGEROUS ALSO THE ODOMETER AND SPEEDOMETER DO NOT WORK WAS TOLD IT…”
“SAFETY RECALL 09S09 - SCDS (SPEED CONTROL DEACTIVATION SWITCH) ON FORD MODELS MADE AFTER 95 WITH A TEXAS MADE DEACTIVATION SWITCH THAT WAS MADE POORLY. I PURCHASED A 1996 FORD EXPLORER EDDIE BAUER EDITION 4X4 TRUCK IN DECEMBER OF 2016, FROM A PRIVATE PARTY IN NEVADA.THE VEHICLE WAS PURCHASED MAINLY SO I COULD DELIVER AS PART OF MY JOB DESCRIPTION AND NEEDED SOMETHING WITH 4X4 SINCE I LIVE IN SNOW. DID A TEST DRIVE, EVERYTHING SEEMED TO WORK PROPERLY AND DRIVE NICELY, DROVE IT FROM RENO, NV TO PORTOLA, CA ABOUT 62 MILES, EVERYTHING STILL FINE. THE NEXT DAY I GOT INTO THE VEHICLE, WAS HEADING TO THE GAS STATION WHEN I REALIZED THE SPEEDOMETER WAS NOT WORKING PROPERLY, THE ARM WENT TO 20MPH AND DROPPED TO 0 AND THE VEHICLE BEGAN SHIFTED BAD FROM LOW TO HIGH GEARS ON THE AUTOMATIC TRANSMISSION. AS I CONTINUED TO DRIVE, THE RPM WENT HIGH, LITTLE OVER 3RPH AND FELT LIKE THE TRANSMISSION WAS STICKING OVER DRIVE LIGHT FLASHES, THEN THE CHECK ENGINE LIGHT. DID A CODE READER AND SAID MY SEED SENSOR WAS NO GOOD. REPLACED THE VSS, CHECK ENGINE LIGHT WENT OFF FOR ABOUT 15 MILES, THEN SAME ISSUE.I DID A FULL TIME UP, NO CHANGE,DID ANOTHER READING, SAME CODE FOR SPEED SENSOR…”
“SEARCHING BY VIN: [XXX] NUMBER OF OPEN RECALLS: 0 BUT SEARCHING BY MAKE, MODEL, AND MODEL YEAR I FOUND THIS RECALL: HTTP://WWW-ODI.NHTSA.DOT.GOV/OWNERS/SEARCHRESULTS;JSESSIONID=SJ1QWW1GVDDYCS6XGGCHZTLTY2TN4KJKBPXV1GCS9VG9XL8B1ZT5!857755995?PRODTYPE=V&SEARCHTYPE=PROD&TARGETCATEGORY=A&SEARCHCRITERIA.MODEL=EXPLORER&STATS=215181%2C11%2C3%2C1611%2C236%2CEXPLORER&MAKESTATS=&JSONBASEURL=%2FDOWNLOADS%2FFOLDERS%2F&SEARCHCRITERIA.MODEL_YR=1996&SEARCHCRITERIA.MAKE=FORD&SEARCHCRITERIA.PROD_IDS=215181 REPORT RECEIPT DATE: OCT 13, 2009 NHTSA CAMPAIGN NUMBER: 09V399000 COMPONENT(S): VEHICLE SPEED CONTROL THE DEALERSHIP SHOP AND WITH YOUR CHAT REPRESENTATIVE TRIED TO CONVINCE ME THAT THE RECALLS ARE ONLY BY VIN EVEN TOUGH IN YOUR WEB-SITE IT SAYS: "BESIDES THE VIN SEARCH TOOL YOU JUST USED, NHTSA OFFERS ADDITIONAL SAFETY INFORMATION BASED ON A VEHICLE'S MAKE, MODEL, AND MODEL YEAR AND NOT TIED TO ANY PARTICULAR VIN. A SEARCH BY VEHICLE MAKE, MODEL, AND MODEL YEAR GIVES YOU ACCESS TO INFORMATION ABOUT TECHNICAL SERVICE BULLETINS, NHTSA INVESTIGATIONS, AND OWNER COMPLAINTS, AS WELL AS SAFETY RECALLS ON AFTERMARKET EQUIPMENT THAT IS OFTEN NOT LINKED TO A PARTICULAR VIN OR EVEN TO…”
“15 MINUTES AFTER PARKING THE VEHICLE AND GETTING OFF THE VEHICLE CAUGHT ONFIRE UNDER THE HOOD IN THE DRIVERS SIDE. THE FIRE EXPANDED QUICKLY CAUGHT DRIVERS SIDE FRONT TIRE AND MOVED ON TO THE ENTIRE MOTOR BEFORE THE FIREFIGHTERS CAME AND STOPPED THE FIRE. *TR”
“THE VEHICLE BEGAN HESITATING DURING TAKEOFF, ALLOWING THE ENGINE TO EXPERIENCE HIGH RPM'S BUT VERY LITTLE ACCELERATION. THE VEHICLE THEN BEGAN TO NOT FALL INTO 1ST GEAR, WHEN YOU SHIFTED THE CAR INTO DRIVE FROM PARK THE VEHICLE WOULD HESITATE FOR ABOUT 4 SECONDS THEN LURCH HEAVILY, THE VEHICLE ALSO DOES THIS AT EVERY STOP, AFTER YOU MAKE A COMPLETE STOP AND PRECEDE TO ATTEMPT TO DRIVE AGAIN THE VEHICLE WILL RPM AS YOU PUSH THE ACCELERATOR BUT WON'T MOVE FOR ABOUT 4 SECONDS, AFTER THE 4 SECONDS THE VEHICLE LURCHES FORWARD HEAVILY AND SPINS BOTH REAR TIRES. *TR”
“TL* THE CONTACT OWNS A 1996 FORD EXPLORER. THE CONTACT WAS DRIVING 80 MPH WHEN THE VEHICLE EXHIBITED AN ABNORMALLY LOUD SNAPPING SOUND AS THE ACCELERATOR PEDAL TRAVELED TO THE FLOORBOARD. THE CONTACT STATED THAT THE ASSEMBLY FRACTURED FROM THE FIREWALL AND CAUSED THE VEHICLE TO DECELERATE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 100,000.”
Showing 6 of 146 reports. Read every report on NHTSA.gov.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.