2016 Ford Explorer power train problems

“On approximately 09/02, I took my 2016 Ford Explorer to an authorized Ford dealership for recall-related PCM service. After the recall service was completed, I experienced additional problems with the vehicle and returned on 09/4 and I also called the same dealership that same day because I believed something was wrong following the repair. The dealership replaced the battery but did not perform additional diagnostics unless I paid out of pocket. I was unable to immediately afford those diagnostic charges, so I later sought additional diagnosis. The vehicle continued to experience drivability/electrical problems, including misfire symptoms and eventually a no-start condition. After further testing, another authorized Ford dealership diagnosed the PCM as faulty. I contacted Ford Motor Company because I am concerned that the recall service, programming, or work performed during the recall may have contributed to the PCM failure. Ford closed my case because the recall was marked completed and stated that my vehicle is outside its warranty period. I returned the vehicle two days after servicing dealership as the recall repair to report problems. I am requesting…”

“The contact called on behalf of his wife, who owns a 2016 Ford Explorer. The contact stated that while reversing at an undisclosed speed, the vehicle independently accelerated. The check engine warning light was illuminated. The contact researched online and was made aware of NHTSA Campaign Number: 25V164000 (Power Train); however, the VIN was not included. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 155,000.”

“My 2016 ford explorers torque converter has failed. It causes a extremely rough idle while in drive or reverse, the rpms vary and at a complete stop the car will continue to lunge forward. If I were to continue to drive the vehicle at any point without warning my transmission could completely lock up causing me to stall in the middle of the road. The dealership has confirmed it as well as ford and ford has an active recall for my specific car but my vin isn't covered under the recall and ford is refusing any sort of fault.”

“Vehicle: 2016 Ford Explorer 2WD V6-3.5L VIN: [XXX] rchase: January 20, 2026 Odometer at Purchase: 70,929 miles (fraudulent — true mileage approximately 123,779 miles) Dealer: Drive Time Car Sales Company LLC, DBA Drive Time, 8805 E Adamo Dr, Tampa, FL 33619-3525 Narrative — Copy and Paste Into NHTSA Online Form: On January 20, 2026, I purchased a 2016 Ford Explorer 2WD V6-3.5L (VIN: [XXX] ) fr [XXX] Sales Company LLC, located at 8805 E Adamo Dr, Tampa, Florida 33619-3525. At the time of sale, the vehicle had three open, unrepaired federal safety recalls: 1. NHTSA Recall 19V435 / Ford 19S17 — Rear Suspension Toe Link Replacement (initiated June 26, 2019, affecting 1,194,173 vehicles). The rear suspension toe links may fracture, causing sudden loss of vehicle handling and risk of crash. 2. NHTSA Recall 21V537 / Ford 21S32 — Rear Suspension Toe Link Cross-Axis Ball Joint (owner notifications mailed March 2022, affecting 644,055 vehicles). The cross-axis ball joint may corrode and seize, causing toe link fracture and loss of steering control. 3. NHTSA Recall 25V347 / Ford 25S53 — B-Pillar Door Trim Detachment (owner notifications mailed June 2025, affecting 492,145…”

“When I am driving at a speed limit of 35-45 mph, there is a shutter in my transmission accompanied by a rattling noise. It only happens at that range of speed, below 35 and above 45 it seems to work just fine. If I have to drive a considerate amount of time at that speed, it does it constantly and I can't make it stop. It feels like the transmission will blow up. I have seen multiple articles and recalls for the torque converter in the 2016-2020 models, but apparently my VIN number isn't included, although the symptoms are exactly like the open recall symptoms of other Explorers. I have taken it to a transmission shop to get it test driven and diagnosed and they agreed that it did feel like the torque converter was slipping, but their advise was to rebuild the whole transmission since there wasn't any recalls specifically for my VIN number. It does not show any messages or have any warning lights about this issue on the car itself, I don't know if the computer recognizes these type of issues or not.”

“Transmission was rebuilt by Asheville Ford three years ago we’d only put 40,000 miles on it and now it needs a new transmission. We did bring it to another Ford and they had to reseal the casing saying the original sealant wasn’t done right”