2016 Ford Explorer steering problems

“What component or system failed or malfunctioned, and is it available for inspection upon request? Yes How was your safety or the safety of others put at risk? Yes: While driving on [XXX] at highway speed, my vehicle suddenly began to swerve, causing a significant loss of steering control and creating an unsafe driving condition. Concerned that I had experienced a flat tire, I immediately pulled over to inspect the vehicle. Upon inspection, I found that none of the tires were flat. Believing it was unsafe to continue at normal speed, I proceeded cautiously and drove the vehicle slowly to my service center for diagnosis. After examining the vehicle, the service center informed me that the rack and pinion steering assembly was the cause of the problem I experienced. At the time of the incident, I had an extended warranty/service contract that provided powertrain coverage. However, I was informed that because the rack and pinion system in my vehicle is electronically assisted, the repair was not covered under the terms of the policy. Given the sudden loss of steering control and the potential safety risks involved, I am seeking a review of this matter by your…”

“1. What component or system failed or malfunctioned, and is it available for inspection upon request? The exterior B-pillar trim on the side of the vehicle became detached while the vehicle was being driven. After the trim became loose and was temporarily secured by a Ford dealership, the vehicle's security system malfunctioned, the tailgate would not open, and the vehicle would not shut off normally. The trim piece is currently taped in place. 2. How was your safety or the safety of others put at risk? The trim detached while I was driving and was flapping against the vehicle. There was a risk that the part could have completely separated from the vehicle and struck another vehicle, pedestrian, or object in the roadway. I was also distracted while attempting to manage the situation and find a safe place to stop. Operating a vehicle with components coming apart created an unsafe condition for me and other motorists. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. A Ford dealership observed the detached trim and temporarily secured it with tape. The trim was later repaired; however, the same component has detached…”

“Approximately 3 years ago, while driving my 2016 Ford Explorer on a [XXX], warning chimes sounded and a power steering/steering assist fault message appeared. Electric power-steering assist then stopped functioning and the steering became extremely difficult to operate. I slowed down and was able to maneuver safely off the freeway. I shut the vehicle off, opened the driver’s door, waited approximately 45 seconds and restarted it. Normal steering assist returned. Shortly afterward, I took the vehicle to Oakdale Ford in Oakdale, CA and reported the problem. I was advised that further diagnosis/investigation would involve approximately 5,600 in costs. I declined due to the expense, and no repair was performed. The cause of the failure remains UNKNOWN. The vehicle remains available for inspection. During the approximately 3 years since, the vehicle has unexpectedly lost electric power-steering assist at least a dozen additional times, at different speeds and on different types of roads. Sometimes warning chimes/messages occur without loss of assist; other times assist is actually lost. Shutting the vehicle down, opening the driver’s door, waiting approximately 45…”

“Hello. I purchased my car in 2018. 2-3 years later, the power steering would randomly go out while driving - on the highway and city roads. This could happen once and then not again for 6+ months. When this happened a message would display about a "steering assist fault, service now". I found that if I pulled over, turned the car off and then on, it would generally work again. We had the vehicle in to 3 separate repair shops between 10/2022 and 10/2025 and no one could diagnose the issue as they needed it to replicate the condition. (In hindsight find this strange (concerning!!) as a simple google search shows what I am describing is a very common issue with a number of Ford models and also other vehicles.) In June 2026, while on vacation with my family (on a mountain) it happened again. We turned the car on and off several time, disconnected/reconnected the battery and could not get the car to start working again and this time the steering wheel was completely locked. We had the vehicle towed and rented a car to drive home. The dealership was able to diagnose and repair the issue by replacing the entire steering rack assembly. No issues since then.”

“2016 Ford Explorer, VIN [XXX]. Filing against Planet Ford Dallas regarding incomplete Regional Program 21R01 (Rear Toe Link Replacement), tied to Federal Safety Recall 21V537. May 11, 2026: Vehicle presented for 21R01 service. May 15: Returned with recall marked complete in Ford's system. 21R01 mandates replacement of both rear toe links, alignment check, and rear toe adjustment. None of these steps were correctly completed. Dealer has since acknowledged to me that the toe link was not replaced correctly, but instead with the incorrect part and that rear suspension hardware was left loose upon vehicle release. The vehicle was driven approximately one month in this condition. Progressive symptoms followed: steering pull, steering wheel offset, tire screeching, and vehicle instability. Rear toe was subsequently found approximately 3 degrees out of specification — consistent with loose hardware shifting during normal driving. Dealer is attributing front suspension wear to natural causes while providing no investigation demonstrating the incomplete recall did not contribute to or accelerate that damage. Ford Motor Company Head Office has confirmed 21R01 as…”

“The electronic power steering failed Yes its available for inspection My child and my safety were put at risk when I warning came up and said "steering loss, stop safely" and the steering wheel was locked. The problem was still there when it was brought into Ford service center Nothing prior to the warning”