2014 Ford F-150 structure problems

“The contact owns a 2014 Ford F-150. The contact stated that the transmission was not functioning properly. There was no warning light illuminated. The vehicle was taken to an independent mechanic and the contact was informed that corrosion had caused two holes underneath the sub frame of the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 185,000.”

“Both rear doors would not open from the outside or inside. They were not locked. They just would not open using the handle inside, trying to pull up on the lock mechanism and unlocking and locking numerous times. The doors would still not open. A child and a dog were in the back seat. I could not access them from the doors had to bring them through the front of the vehicle, which was very difficult. Periodically one door will be OK to open, the next day the door will not open, may or may not depending on how the door feels like working that particular daynot open.”

“I have owned this F-150 since new and most of its life it has been stored indoors. Recently I noted that any time the vehicle is driven in the rain or left outside while it rains, the rear corners of the cab leaks water. The source of that water is a failed seal surrounding the rear window, which I diagnosed in my shop after removing the headliner and other trim in order to observe the leaking with some water and compressed air. The issue that I noted during the repair was that the airbags that are mounted above the rear passenger windows in the headliner on both sides of the vehicles wicked up moisture that had been caught by the headliner. They were both wet to the touch, which was concerning. Further, the airbag inflator which is mounted in the rear corner post of the vehicle and the seatbelt recoil mechanism both also showed signs that they also recieve moisture from this leak. The vehicle is out of warranty, so there is no manufacturer remedy for the issue unless I were to pay for a complete rear window reseal. I did not have a dealer take a look at this issue at this time. Multiple other owners of F150's of this age have had similar issues with water…”

“The contact owns a 2014 Ford F-150. The contact stated that while the vehicle was parked, the contact became aware that the passenger’s side window trim panel was separating from the vehicle. The vehicle was taken to a dealer where it was diagnosed that the trim panel needed to be replaced. The vehicle was repaired, but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 20,426.”

“The contact owns a 2014 Ford F-150. The contact stated that upon removing the passenger's side floor mat after it rained, the contact noticed that the carpet was significantly wet. The contact then discovered that the carpet showed the presence of mold. Additionally, the contact stated that the bolts securing the front passenger’s and driver’s seats to the chassis were corroded. The dealer was notified of the failure and informed the contact that it was a known failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 87,000.”

“The rear window in my F150 has rear defrost with a power sliding window. The glass panel on the drivers side has spontaneously shattered two time. Once in October 2020 and again in April 2022. On both occasions the glass was spiderwebbed but had not fallen out. There was no indication that the glass had any physical damage from the exterior or interior. Also, the vehicle had been parked the first time while at home and the second time while at work.”