2014 Ford Flex suspension problems

“Without warning, the vehicle's power steering stopped working in an intersection while turning. The hazard lights came on automatically and I used my full body strength to steer the car out of the intersection. Inspection showed a computer module failure within the steering rack. Because the computer module is built into the steering rack, the whole steering rack needed to be replaced. This was a critical repair and cost over $3500.”

“I have a 2014 Ford Flex. My axle shaft came undone while driving. My Ford flex was manufactured 07 of 13 my mechanic said that there's a recall for your front axle shaft on the passenger side and it falls within the guidelines of the affected vehicles but Ford says that it's not covered. My vin was never added to the recall and it’s the same exact issue that the others had for that year.”

“The contact owns a 2014 Ford Flex. The contact stated while driving at various speeds, the vehicle was fishtailing, causing the contact to lose control of the rear end of the vehicle. The contact stated that the failure was causing the tires and brakes to wear out prematurely, and had caused the tires to cave in. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure and informed the contact that the vehicle was previously repaired under NHTSA Campaign Number: 14V393000 (Power Train); however, the failure persisted. The failure mileage was approximately 113,000.”

“The contact owns a 2014 Ford Flex. The contact stated that while her wife was driving at an undisclosed speed, she became aware that the electronic power steering was not functioning properly after the steering wheel jerked in the right direction. As a result, the driver lost control of the vehicle and collided with a dividing wall on the side of the roadway. The vehicle returned to normal functionality, but the failure became a regular occurrence. The air bags did not deploy. No warning lights were illuminated. A police report was not filed, and no injuries were reported. The vehicle was taken to an independent mechanic, who diagnosed a failure with both control arms. The vehicle was repaired, but the failure reoccurred. The vehicle was then taken to the dealer, who was able to duplicate the failure but was unable to provide a diagnosis. The vehicle was not repaired. After investigating the failure, the contact related the failure to Safety Recall 15S18. The contact also stated that before the control arm failure, upon entering the vehicle and attempting to start the ignition, the vehicle failed to start as intended. No warning lights were illuminated. The…”

“The contact owns a 2014 Ford Flex. The contact stated while driving approximately 45 MPH the steering wheel felt like it slipped. There were also unknown noises from the steering wheel when turned left. The brake warning light was illuminated. The vehicle was taken to the local dealer and diagnosed with NHTSA Campaign Number: 20V072000 (Suspension). The vehicle had not been repaired. The manufacturer was notified of the failure. The approximate failure mileage was 20,000”

“The vehicle was repaired under recall 20V-072. This was for the rear suspension toe link. The replacement rear suspension toe link on the right side has cracked. This was discovered when the right rear wheel was removed for tire replacement. I have a photo of the failed toe link part.”