2014 Ford Focus power train problems

“The Transmission Control Module (TCM), within the PowerShift DPS6 Automatic Transmission, failed completely on a 2014 Ford Focus (72,000 miles). The failed component is no longer physically available for inspection as it was retained by the independent service facility as a core replacement, but full repair invoices and diagnostic documentation are available. The failure caused a sudden and unpredictable loss of forward motive power, severe gear hesitation, and failure to engage drive gears while operating the vehicle. The gears would slip and it made continuous forward acceleration at the speed limit nearly impossible. This created an immediate hazard of being rear-ended and/or stranded in ongoing traffic without acceleration capability. Shortly afterwards it also completely lost the ability to reverse. The problem was formally reproduced, diagnosed, and confirmed by an independent repair facility during service. The vehicle has not been inspected by the manufacturer, police, or insurance representatives. A Check Engine Light illuminated came on at approx 72,000 miles while I was running morning errands. The light came on as I started feeling some sudden rough…”

“The contact owns a 2014 Ford Focus. The contact stated that while driving approximately 30 MPH and coming to a stop, the vehicle unexpectedly stalled, and the transmission was slipping with the message “Transmission Overheated - Stop Vehicle” displayed. There was an abnormal odor coming from the vehicle while stopped. The contact stated that the vehicle was restarted, shifted to neutral, and remained stopped for 10 minutes before the vehicle returned to normal operation. The failure had occurred several times. Eventually, the vehicle was unable to be started. The vehicle was towed to the dealer, where it was diagnosed and determined that the clutch actuator and throw-out bearing had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 133,283.”

“The transmission over heating light comes on and says stop safely or wait 5 mins you can be going down the road and it jumps out gear and want go anywhere and it very dangerous.and I want no if ford fixes the problem.”

“I own a 2014 Ford Focus Titanium with approximately 75,000 miles and the DPS6 automatic transmission. The transmission has developed a serious and recurring problem. The vehicle began violently jerking/shuddering while moving forward and suddenly would not go into reverse. A transmission warning light came on. After the battery was recharged, reverse temporarily returned, but the same transmission problems came back while driving. The vehicle was diagnosed with trouble code P090C:68, related to the clutch actuator system. Ford has known about recurring DPS6 transmission problems in these vehicles for years and has issued multiple technical service bulletins and customer programs addressing transmission clutch shudder, shifting problems, loss of engagement, and related failures. Ford’s own documentation has acknowledged conditions that can result in loss of transmission engagement, loss of power, and other driveability problems. My Ford dealer told me Ford has known about this problem for a long time but considers it not to be a safety issue and therefore will not pay for the repair. The dealer estimated the repair at $6,077.31, and I was charged $159 for the…”

“The contact owns a 2014 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle was shaking erratically, and the vehicle stopped independently. No warning lights were illuminated. The vehicle was turned off. The contact stated that while attempting to start the vehicle, the vehicle restarted; however, the failure was persistent. The vehicle was taken to Auto Zone, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 174,400.”

“The contact owns a 2014 Ford Focus. While the contact’s son was driving at an undisclosed speed, the vehicle stalled. The vehicle was towed from the scene of the failure. The dealer was contacted and diagnosed the vehicle with a transmission module failure. The vehicle was repaired. The contact associated the failure with an unknown recall associated with the powertrain; however, the VIN was not under recall. The manufacturer was made aware of the failure but offered no assistance with repairing the vehicle. The failure mileage was approximately 100,000.”