2014 Ford Focus problems

“The Transmission Control Module (TCM), within the PowerShift DPS6 Automatic Transmission, failed completely on a 2014 Ford Focus (72,000 miles). The failed component is no longer physically available for inspection as it was retained by the independent service facility as a core replacement, but full repair invoices and diagnostic documentation are available. The failure caused a sudden and unpredictable loss of forward motive power, severe gear hesitation, and failure to engage drive gears while operating the vehicle. The gears would slip and it made continuous forward acceleration at the speed limit nearly impossible. This created an immediate hazard of being rear-ended and/or stranded in ongoing traffic without acceleration capability. Shortly afterwards it also completely lost the ability to reverse. The problem was formally reproduced, diagnosed, and confirmed by an independent repair facility during service. The vehicle has not been inspected by the manufacturer, police, or insurance representatives. A Check Engine Light illuminated came on at approx 72,000 miles while I was running morning errands. The light came on as I started feeling some sudden rough…”

“The contact owns a 2014 Ford Focus. The contact stated that upon reversing, the rear-view camera displayed a blank screen. The message "See the Dealer" was displayed, and the check engine warning light remained illuminated. The contact stated that the vehicle experienced a slight loss of automotive power while driving uphill and the steering became very loose. The contact stated that while turning to the left or the right, the steering wheel failed to return to center. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact associated the failures with NHTSA Campaign Numbers: 26V369000 (FUEL SYSTEM, GASOLINE) and 14V514000 (STEERING); as possible causes for the failure. The manufacturer was notified of the failure. The failure mileage was 83,000.”

“The vehicle has a recurring fuel-level/distance-to-empty (DTE) malfunction that has caused it to run completely out of fuel and lose motive power while the instrument cluster indicates substantial remaining range. This has occurred four times. On the first three occasions, the vehicle ran out of fuel while displaying approximately 28-30 miles DTE. On two occasions, including the most recent, the engine shut off unexpectedly in the roadway and other motorists had to help push the disabled vehicle out of traffic. During the most recent incident, the vehicle displayed approximately 35 miles DTE when the engine shut off. There was no sputtering, warning message, warning lamp, or other indication that the vehicle was actually out of fuel. I previously brought the vehicle to an independent repair facility specifically for the inaccurate fuel/DTE indication and occasional stall-like behavior. Fuel trims were checked and no obvious cause was identified. I subsequently learned that Ford Safety Recall 18S32 had been performed on this vehicle in 2021, before I owned it. That recall addressed excessive fuel-tank vacuum/possible tank deformation and identified symptoms…”

“My 2014 Ford Focus with a DPS6 dual-clutch transmission began experiencing severe shuddering and harsh shifting. A Ford dealership confirmed the concern and diagnosed DTC P07A3 — Transmission Friction Element A Stuck On — using Ford's prescribed pinpoint test. Recommended repair exceeds $4,000. Vehicle is available for inspection. This is a recurring failure on this specific vehicle. Ford's own warranty history documents six prior DPS6 repairs between 2016 and 2023, including two full clutch replacements, three TCM/PCM reprogramming sessions, and a full TCM replacement under program 14M02 — all at Ford dealerships. The current failure occurs just 35,000 miles after Ford's most recent transmission repair. Prior repair orders document dangerous safety events including sudden loss of drive while in motion, no-start conditions, and complete loss of throttle control on the highway — consistent with the known DPS6 failure pattern. Ford issued six Customer Satisfaction Programs covering this transmission over eleven years — 14M01, 14M02, 15B22, 19N07, 19N08, and 14M02 Supplement 7 — acknowledging a persistent design defect. Despite this documented repeat failure…”

“The contact owns a 2014 Ford Focus. The contact stated that upon starting the vehicle, the "Steering Wheel Alert Malfunction" message displayed on the instrument panel, and the steering wheel seized. The vehicle was rendered inoperable. Upon research, the contact associated the failure with Customer Satisfaction Program: 15N01 (EPAS Steering Efforts); however, the VIN was not included. The failure mileage was 145,145.”

“I am submitting this complaint regarding ongoing transmission and Transmission Control Module (TCM) issues with my 2014 Ford Focus. In October 2022, the transmission was replaced, yet I continue to experience serious transmission-related failures. Most recently, the vehicle would only start in neutral and would not reliably shift into drive or reverse. These recurring issues have made the vehicle unreliable and unsafe. I have contacted Ford Customer Service three separate times seeking assistance and a permanent resolution. Despite these efforts, I have not been provided with a fix that addresses the root cause of the problem. Ford has long been aware of widespread TCM issues affecting certain Ford Focus models, making the continued failure of this vehicle especially concerning. My greatest concern is safety. During a recent incident, the vehicle unexpectedly slammed into gear with significant force while my son and I were inside. The sudden engagement nearly caused me to lose control of the vehicle and almost sent us into a ditch. Had road conditions or traffic been different, the outcome could have been much worse. I have dash camera footage documenting the…”