2013 Ford Fusion Hybrid engine and engine cooling problems

“The contact owned a 2013 Ford Fusion. The contact stated while driving 75 MPH, there was smoke coming from the engine compartment. The contact stated that the message "Coolant Over Temperature" was displayed. The contact pulled over to the side of the road and turned off the vehicle. The contact then exited the vehicle and raised the hood and there was black smoke coming from the engine compartment. The contact backed away from the vehicle and approximately 3 minutes later the vehicle caught on fire. The Fire Department was contacted and arrived at the scene and extinguished the fire. A Fire report was filed however, the contact had not received a Fire report number. The Police also arrived on scene and collected information from the contact; however, the contact was unaware of a Police report being filed. There was no injury sustained. The vehicle was towed to an impound lot. The contact was made aware that the VIN was included in NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling). The contact stated that the vehicle was destroyed. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 155,000.”

“The contact owns a 2013 Ford Fusion. The contact stated while driving 65 MPH, the low oil pressure warning light illuminated, and there was smoke coming from underneath the hood. The contact pulled over to the side of the road and opened the hood to inspect the vehicle. The contact stated that upon opening the hood, the contact became aware that oil was leaking at the rear of the engine compartment by the firewall. The vehicle was towed to the residence. The vehicle was then towed to an independent mechanic, where it was diagnosed that the cylinder head had fractured. The mechanic determined that the failure was related to NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling). The vehicle was in the process of being repaired. The dealer was not contacted. The manufacturer was notified of the failure. The failure mileage was approximately 150,000.”

“The contact owns a 2013 Ford Focus. The contact stated that while driving on the highway at 55 MPH, the temperature gauge indicated that the engine was hot(H). No warning lights were illuminated. The contact exited the highway, however, upon pulling over to the side of the road, the vehicle shut off and coasted to a stop. The vehicle was towed to a local independent mechanic where the vehicle was diagnosed, and the contact was informed that the engine had experienced coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 130,000.”

“The contact owns a 2013 Ford Fusion. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however, the vehicle failed to accelerate as intended and the vehicle lost motive power. The contact safely guided the vehicle to the shoulder of the road. In addition, the contact noticed white smoke coming from under the hood. The vehicle was towed to the dealer where it was diagnosed with coolant intrusion to cylinder #3. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that recall repair NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling) was performed, however it did not remedy the failure because the head gasket was warped. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was unknown.”

“The contact owns a 2013 Ford Fusion. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that there was coolant intrusion into the cylinder and that the engine needed to be replaced. The contact researched and was made aware of NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that the VIN was not included in the recall. The failure mileage was approximately 60,000.”

“The contact owns a 2013 Ford Fusion. The contact stated that while the vehicle was parked, the contact noticed coolant leaking underneath the vehicle. The low coolant warning light was illuminated. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer referred the contact to the manufacturer for further assistance. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 139,753.”