2011 Ford Fusion steering problems

“My mom’s 2011 Ford Fusion SEL experienced a loss of electric power steering assistance. I cannot determine the exact moment the failure occurred. When I started the vehicle and attempted to drive away, I noticed that the steering wheel was extremely stiff. The dashboard displayed a “Power Steering Assist Fault” warning. The steering assistance has not returned, including after replacing the vehicle’s battery. I diagnosed the vehicle using FORScan, which identified the following diagnostic trouble codes in the Power Steering Control Module (PSCM): U3000:96-C8 — Control Module, Component Internal Failure. C200C:2F-48 — Steering Shaft Torque Sensor 2, Signal Erratic. Both codes were recorded as previously set and not present at the time of the diagnostic request. However, the power steering warning remains displayed and the steering wheel remains extremely difficult to turn with the engine running. This vehicle was previously included in Ford Safety Recall 15S18 / NHTSA Recall 15V340, addressing loss of electric power steering assistance. Ford confirmed that the recall was completed in 2015 through reprogramming the Power Steering Control Module only rather than…”

“The contact owns a 2011 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle suddenly lost power steering assist, nearly causing the contact to lose steering control as the steering locked up, and an audible warning chime sounded. The contact safely maintained control of the vehicle and observed that a power steering warning light was illuminated. The contact associated the failure with NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The vehicle was towed to the residence. The manufacturer was notified of the failure. The failure mileage was 100,000.”

“I am filing an official complaint against Grieco Ford of Fort Lauderdale regarding Safety Recall 15S18 (NHTSA Campaign 15V340) for my 2011 Ford Fusion. The official recall status is 'Recall Incomplete'. The dealership refused to perform the mandatory safety repair, claiming that the vehicle's factory warranty has expired. According to federal law, safety recalls do not expire and must be performed free of charge regardless of warranty status. Because of this unlawful refusal, my vehicle remains deactivated on Lyft, causing me immediate loss of income. Please investigate this dealership's failure to remedy a federal safety recall.”

“The contact owns a 2011 Ford Fusion. The contact stated that while driving at various speeds, the steering wheel became stiff and excessive force was needed to make a left or right turn. The power steering assist and Advancetrac warning lights were illuminated. The vehicle was taken to a local dealer where it was diagnosed and confirmed that the rack and pinion needed to be replaced. The contact stated that the vehicle was previously taken to a local independent mechanic; however, the failure was not duplicated. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000.”

“The contact owns a 2011 Ford Fusion. The contact stated that while his daughter was driving 35 MPH and making a turn, the vehicle almost crashed into the neighbor's lawn because the steering wheel had seized. The contact's daughter stated that the steering wheel was firm and required extra effort to turn the steering wheel. Additionally, at the time of the failure, the contact's daughter claimed that there were three dinging sounds, like when putting the keys into the ignition of the vehicle. An unknown warning light was illuminated. The failure was a recurring failure. The contact associated the failure with NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The dealer was contacted. The manufacturer was contacted by phone and made aware of the failure. The failure mileage was approximately 211,000.”

“Turning on my car and the message power steering asstist fault comes on. Turning g off the car would work for awhile but not now. We got a new battery and that didn't help. I had the recall done in 7/30/2015. I called Ford 10/2/2026 and they said even tho I had very low miles the 10 years had passed first so the one time fix wouldn't apply. Someone may call me from Ford to ask further details. Also advised to save receipts on any repairs I do in case there is a chance down the road I can be reimbursed! I said that's absurd Ford isn't standing behind this issue, knowing it's an ongoing problem with many of the cars since the recall was done!”