NHTSA lists 4 safety recalls and 43 owner complaints for the 1997 Ford Probe. Most complaints involve engine and engine cooling (16) and power train (5). The EPA rates it 20–25 mpg combined.
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
CERTAIN SPX FILTRAN FUEL FILTERS WITH A 45-DEGREE ANGLE INLET TUBE, MODEL 800F350-S1, SOLD AS REPLACEMENT FILTERS FOR 1993-1997 FORD PROBE,1993-2001 MAZDA 626 AND MX-6, AND 1983-1994 LOYAL, 3-DOOR COUPE, HATCHBACK, SEDAN, WAGON, BRAT, DL, GL, GL-10, RX, XT, AND XT6 PASSENGER VEHICLES WITH EFI OR TURBO ENGINES. THESE FILTERS ARE PACKAGED AS WIX, NAPA, AND CARQUEST BRAND FUEL FILTERS. CERTAIN SPX FILTRAN FUEL FILTERS WITH A 90-DEGREE ANGLE INLET TUBE, MODEL 800F300-S2, SOLD AS REPLACEMENT FILTERS FOR 19983-1994 SUBARU VEHICLES WITH EFI OR TURBO ENGINES. THESE FILTERS ARE PACKAGED AS WIX, NAPA, AND CARQUEST BRAND FUEL FILTERS. FUEL MAY LEAK FROM THE FILTER DUE TO NON-CONFORMING BRAZING WELDS WHERE THE INLET TUBE IS CONNECTED TO THE FILTER CAN.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“INCIDENT LIKE MANY OTHERS I HAVE HAD MY 1997 FORD EXPEDITION XLT BLOW A SPARK PLUG OUT OF THE CYLINDER HEAD. THE VEHICLE WAS RUNNING FINE AND TROUBLE FREE WHEN A POP FROM UNDER THE HOOD AND A LOUD BANGING NOISE CAME FROM THE ENGINE HEAD. THE VEHICLE WAS TOWED TO THE REPAIR SHOP ; WHO IN TURN CALLED THE LOCAL FORD DEALER. THE REPLY WAS THEY NEVER HEARD OF THIS PROBLEM BEFORE. MY LOCAL SERVICE TECH SAID THE REPAIR KIT ALONE WOULD COST $1,000,00. TO REPAIR IT HE SAID THAT FORD HAD ONLY USED 3 THREADS IN THE HEAD THAT FAILED, BUT ARE NOW REPLACING THEM WITH A 7 THREAD HEAD., THIS TELLS ME THAT THEY ARE VERY AWARE OF THE PROBLEM BUT ARE WILLING TO LEAVE THEIR CUSTOMERS OUT TO DRY.. I GUESS THE SCARY PART ABOUT THAT IS I STILL HAVE 4 MORE 3 THREAD SPARK PLUG HOLES TO WORRY ABOUT BLOWING OUT,.I ABSOLUTELY FEEL THIS SHOULD BE THE RESPONSIBILITY OF FORD MOTOR COMPANY WHO IS LOOKING FOR THE AMERICAN PUBLIC TO BUY IT'S TRUCKS. DAMAGE RESULTING IT WILL COST ME AS LITTLE AS $2,500.00 TO REPAIR THE CURRENT PROBLEM ( AND NO GUARANTY IT WON'T HAPPEN AGAIN). OR UP TO $5,500.00 TO REPLACE THE BUILT TOUGH 5.4 TRITON ENGINE. *TR”
“I HAVE A 1997 FORD PROBE GT 6 CYLINDER. THE OVER DRIVE LIGHT KEEP FLICKERING OVER DRIVE OFF AND THEN CHECK ENGINE LIGHT STAYS ON FOR DAYS. I HAD THIS CHECKED OUT AND THE TPS THROTTLE POSITION SENSOR CHECK OUT BAD SO I HAD THIS REPLACED. THIS PROBLEM STILL EXIST. I WENT TO SEVERAL SERVICE STATIONS THEY ALL SAY I DON'T KNOW. I WOULD JUST IGNORE THIS BUT THE SLOWS DOWN TO LOWER GEAR THIS IS SCARY. I LOVE THIS FORD PROBE IS THERE ANYTHING I CAN DO. I FOUND A SIGHT ON THE INTERNET AND RELAYED A INTERCOOLING FOR THE TRANS, IS THIS CORRECT!!! *NM”
“1997 EXPEDITION SPONTANEOUSLY CAUGHT FIRE IN THE DRIVEWAY 45 MINUTES AFTER IT HAD BEEN DRIVEN. THE FIRE DEPARTMENT AND POLICE CAME AND PUT OUT WHAT WAS ALMOST A CATASTROPHIC HOUSE FIRE. THE TRUCK WAS A TOTAL LOSS. TO REPLACE IT WITH SOMETHING COMPARABLE WE BOUGHT A 99 EXPEDITION. WE WERE OUT $8000 IN THE TRADE. THE OLDER EXPEDITION HAD ONE CAR PAYMENT LEFT ON IT BEFORE THE FIRE. NOW I AM HORRIFIED THAT WE HAVE ANOTHER ON IN THE DRIVEWAY.*AK”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Probe Man 5-spd, 4 cyl, 2.0 L · Front-Wheel Drive | 23 | 30 | 25 | $2,550 | 355 |
| Probe Auto 4-spd, 4 cyl, 2.0 L · Front-Wheel Drive | 20 | 28 | 23 | $2,800 | 386 |
| Probe Man 5-spd, 6 cyl, 2.5 L · Front-Wheel Drive | 18 | 24 | 21 | $3,800 | 423 |
| Probe Auto 4-spd, 6 cyl, 2.5 L · Front-Wheel Drive | 18 | 24 | 20 | $4,000 | 444 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
4 safety recalls as of Oct 30, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 43 complaints with NHTSA. The most-cited components are engine and engine cooling (16), power train (5), electrical system (5). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 1997 Ford Probe at 20–25 mpg combined, depending on engine and drivetrain (4 versions rated).