NHTSA lists 7 safety recalls and 427 owner complaints for the 1997 Ford Ranger. Most complaints involve tires (58) and fuel system, gasoline (55). The EPA rates it 16–22 mpg combined.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
Complaints for each Ranger model year we’ve synced.
| Model year | NHTSA complaints |
|---|---|
| 1996 | 430 |
| 1997 | 427 |
| 1998 | 597 |
| 1999 | 785 |
| 2000 | 729 |
| 2001 | 558 |
| 2002 | 389 |
| 2003 | 243 |
| 2004 | 405 |
| 2005 | 289 |
| 2006 | 272 |
| 2007 | 270 |
| 2008 | 326 |
| 2009 | 169 |
| 2010 | 164 |
| 2011 | 235 |
| 2019 | 272 |
| 2020 | 130 |
| 2021 | 119 |
| 2022 | 38 |
| 2023 | 19 |
| 2024 | 97 |
| 2025 | 45 |
| 2026 | 0 |
“I HAD FIVE (5) BF GOODRICH RADIAL ALL TERRAIN TA TIRES FAIL WHILE DRIVING THE SAME VEHICLE OVER ABOUT A TEN YEAR PERIOD. EACH FAILURE IS THE SAME. THE STEEL BELT OF THE TIRE PARTIALLY SEPARATES WHILE ROLLING. THE FIRST OCCURRED ABOUT TEN YEARS AGO ON THE INTERSTATE WHILE PULLING A SMALL FLATBED TRAILER. STEEL BELT THEN WHIPS AROUND INSIDE WHEEL WELL DAMAGING WHATEVER IT COMES IN CONTACT WITH. BF GOODRICH RADIAL ALL TERRAIN TA TIRES WERE ON THIS TRUCK WHEN PURCHASED USED. SECOND TIRE FAILED APPROXIMATELY THREE YEARS AGO THE SAME WAY AT LESS THAN 30 MPH. REPLACED ALL WITH USED SET OF FOUR TIRES WITH 50 % TREAD LEFT. LESS THAN A MONTH AFTER, THIRD TIRE FAILED ON INTERSTATE ONCE AGAIN IN THE SAME WAY. STEEL BELT CUT THE FIBERGLASS REAR OUTER FENDER IN HALF, RIPPED OUT THE REAR WIRING HARNESS, DESTROYED THE LEFT TAIL LIGHT, AND EVEN DAMAGED THE GASOLINE FILL TUBE AND DESTROYED ITS LOCKING GAS CAP FROM THE FORCE OF THE BELT WHIPPING ROUND AND ROUND THE WHEEL, PARTIALLY ATTACHED AND PARTIALLY OFF. NEARLY LOST CONTROL OF VEHICLE, BUT WAS NOT INVOLVED IN ACCIDENT. ALL TIRES FAILED WHILE IN DRIVER'S REAR WHEEL POSITION. THEN LAST MONTH AGAIN, THE LEFT REAR BF GOODRICH…”
“TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT THE REAR FUEL STRAP WAS COMPLETELY RUSTED AND DETACHED FROM THE VEHICLE. THE FRONT FUEL STRAP WAS ALSO RUSTED. THE CONTACT SPOKE WITH THE DEALER AND WAS TOLD THERE WERE NO RECALLS FOR THE FUEL STRAPS ON THE VEHICLE AND PROVIDED NO FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND THE CURRENT MILEAGE WAS 225,000.”
“TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT ONE MINUTE AFTER STARTING, THE VEHICLE FAILED TO SHIFT INTO GEAR AND THE VEHICLE STALLED. THE VEHICLE WAS NOT TAKEN TO THE DEALER, HOWEVER THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 181,000 AND THE CURRENT MILEAGE WAS 181,760.”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Ranger Pickup 2WD Man 5-spd, 4 cyl, 2.3 L · Rear-Wheel Drive | 21 | 24 | 22 | $2,900 | 404 |
| Ranger Pickup 2WD Auto 4-spd, 4 cyl, 2.3 L · Rear-Wheel Drive | 18 | 23 | 20 | $3,200 | 444 |
| Ranger Pickup 2WD Man 5-spd, 6 cyl, 3.0 L · Rear-Wheel Drive | 16 | 22 | 18 | $3,550 | 494 |
| Ranger Pickup 2WD Man 5-spd, 6 cyl, 4.0 L · Rear-Wheel Drive | 16 | 22 | 18 | $3,550 | 494 |
| Ranger Pickup 2WD Auto 4-spd, 6 cyl, 3.0 L · Rear-Wheel Drive | 15 | 21 | 17 | $3,800 | 523 |
| Ranger Pickup 2WD Auto 5-spd, 6 cyl, 4.0 L · Rear-Wheel Drive | 15 | 20 | 17 | $3,800 | 523 |
| Ranger Pickup 4WD Man 5-spd, 6 cyl, 3.0 L · 4-Wheel or All-Wheel Drive | 15 | 20 | 17 | $3,800 | 523 |
| Ranger Pickup 4WD Auto 4-spd, 6 cyl, 3.0 L · 4-Wheel or All-Wheel Drive | 14 | 19 | 16 | $4,000 | 555 |
| Ranger Pickup 4WD Auto 5-spd, 6 cyl, 4.0 L · 4-Wheel or All-Wheel Drive | 14 | 19 | 16 | $4,000 | 555 |
| Ranger Pickup 4WD Man 5-spd, 6 cyl, 4.0 L · 4-Wheel or All-Wheel Drive | 15 | 19 | 16 | $4,000 | 555 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
7 safety recalls as of Nov 5, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 427 complaints with NHTSA. The most-cited components are tires (58), fuel system, gasoline (55), power train (42). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 1997 Ford Ranger at 16–22 mpg combined, depending on engine and drivetrain (10 versions rated).