2014 Ford Taurus fuel/propulsion system problems

“This car has left me stranded multiple times. Took to dealership to find out the fuel pump that had been replaced at 90,000 was dead. Catalytic converter replaced at 125,000. Replaced fuel pump control module, fuel pump and sending unit for the 2nd time in 2014 Ford Taurus SEL AWD with 132,000 miles. Now it is sending a check engine code P0461 which is most likely due to the recent replacement messing with PCM values. The 3.5 DOHC engines should be recalled as well for the fuel system issues along with the other models recalled.”

“There is a recall on 2014 Ford Taurus’ but my VIN does not pop as one that is effective, yet I have all the symptoms. My fuel pump control module, and other various parts of my fuel pump keep failing. Completely lost power in my gas pedal today while on the highway. Couldn’t speed up or do anything. Once I came to a stop, the car wouldn’t start. It would just crank but no turnover. This fuel pump issue has happened 3 times now, but my car is not listed up the recall list. I feel that this is a safety issue and falls under all the same issues that others are having. Can provide receipts showing the previous repairs.”

“The engine light came on and was scanned for engine code P0430 (Catalyst System Efficiency Below Threshold Bank 2). Upon further research, it appears that a catalytic converter has started failing. I was able to clean the catalytic converter, but they are very expensive to replace. Ford issued an extended warranty for this part, but did not issue a recall, despite this being an issue on multiple vehicles. This warranty is 10 years on the Police Interceptor Sedan (Taurus Platform), and 11 years on the Police Interceptor Utility (Explorer Platform). My car's mileage was at approximately 103,000 miles when the light came on. Both warranties extend to 120,000 miles, and my car was two months older than 10 years when this occurred. I contacted Ford through multiple avenues, even writing a letter to Ford Consumer Affairs, and they all declined to extend their warranties to the Ford Police Interceptor Sedan despite the fact that it is identical to the Ford Police Interceptor Utility when it comes to the engine, transmission, PTU, and all components related to those parts, including the catalytic converter. This is a known issue that should have been a recall in the…”

“On 2 occasions in October 2023 my 2014 Ford Taurus would not start after cranking. Once the engine had been warm. The 2nd time approximately 2 weeks later, it was cold and had to be towed to Ford dealer. After the dealer said it was the fuel pump driver module needing replacement, it appears this was a known problem (see below from Ford website); however, mine was not recalled. Mine came from the Chicago factory as well. This should be replaced at no charge to me, including the tow fee. Total $602.90 should be reimbursed. "DEARBORN, Mich., Aug. 24, 2016 – Ford Motor Company is issuing two safety recalls and one safety compliance recall in North America. Details are as follows: Ford issues safety recall for certain 2013-15 Ford and Lincoln vehicles to replace fuel pump control modules Ford is issuing a safety recall for approximately 86,000 2013-15 Ford Taurus, Ford Flex, Lincoln MKS and Lincoln MKT vehicles with 3.5-liter gasoline turbocharged direct injection engines, as well as Ford Police Interceptor sedans to replace fuel pump control modules. In the affected vehicles, the fuel pump control module could fail, which may cause an engine to not start or stall.…”

“The fuel pump control module [XXX] ) failed suddenly and the car failed to drive, I am not driving fast and able to pull over safely. I bought the part part from Ford dealer and replaced the old one, then the problem is fixed. However, as this part fails suddenly and the failing will result in immediate engine stop, it is a safety issue and I shall report it.”

“Vehicle will crank but will not start. Mechanic looked at it and said the module is bad and needs replaced. When replaced, vehicle started fine. There is a recall for this but it is not for my engine type.”