213 owner complaints to NHTSA about the 1999 Ford Windstar cite suspension, 14% of all 1,547 complaints for this model year. NHTSA also lists 4 recalls on this component.
“The contact owns a 1999 Ford Windstar. The contact stated while driving 5 MPH out of the driveway, the vehicle made an abnormal grinding and popping sound. The contact shifted to park(P). The contact stated that upon inspecting the vehicle, the contact noticed that the rear passenger's side tire was pushed inward, and the axle was fractured. The local dealer was contacted and confirmed that an unknown recall was closed. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 103,000.”
“The contact owns a 1999 Ford Windstar. The contact stated that after parking the vehicle, the contact became aware that the rear passenger's side wheel was pushed upward and was nearly rubbing the inner wheel well. The contact stated that upon inspecting the rear axle, he became aware that the rear axle was fractured. The vehicle was towed to the residence. The contact related the failure to NHTSA Campaign Number: 15V608000 (Suspension); and the recall repair was previously performed on the vehicle. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 214,000.”
“The contact owns a 1999 Ford Windstar. The contact stated while driving approximately 55 MPH, he heard the rear driver’s side tire rubbing against the axle and then saw smoke coming from the tire. No warning light was illuminated. The contact then stated that the rear driver's side axle had fractured and was on the ground. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was 130,000.”
“Went into a curve and vehicle swayed and went into the other lane as if had a flat tire. I had it checked at an independent garage and found rear axle is breaking”
“The contact owns a 1999 Ford Windstar. The contact stated that while driving at 35 mph, the vehicle made screeching sounds. The contact saw smoke and detected a burning odor. The vehicle then stalled. The contact was able to pull over and park the vehicle in a parking lot, where it remained. The contact's boyfriend inspected the vehicle and related the failure to the rear axle. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 70,724.”
“TL* THE CONTACT CALLED ON BEHALF OF HIS MOTHER WHO OWNS A 1999 FORD WINDSTAR. THE CONTACT STATED THAT THE DRIVER'S SIDE AXLE FRACTURED, CAUSING THE VEHICLE TO SAG ON THE DRIVER'S SIDE. THE VEHICLE WAS TOWED TO PALLOTTA FORD LINCOLN (4199 CLEVELAND RD, WOOSTER, OH 44691, (330)439-0835) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 15V608000 (SUSPENSION) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 250,000.”
Showing 6 of 213 reports. Read every report on NHTSA.gov.
Ford Motor Company (Ford) is recalling certain model year 1998-2003 Windstar vehicles manufactured September 2, 1997, to July 3, 2003. The affected vehicles were previously remedied to safeguard against the rear axle cracking from corrosion, however, the remedy brackets may have been misinstalled. The incorrect bracket installations may limit the effectiveness of the service repair for NHTSA recalls 10V-385, 12V-193, and 12V-195.
FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, REGISTERED IN PUERTO RICO. DUE TO INCREASED STRESSES CAUSED BY HIGH CYCLES OF TORSIONAL LOADING, SPECIFIC TO THIS MARKET, THE REAR AXLE CAN CRACK.
FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATE OF VIRGINIA. CORROSION-RELATED FRACTURES OF THE FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BODY MOUNT ATTACHMENTS MAY OCCUR.
FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997 THROUGH FEBRUARY 28, 2003 AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. AFTER MANY YEARS OF VEHICLE SERVICE IN THESE AREAS, CORROSION CAN WEAKEN THE REAR AXLE, MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH IF UNDETECTED CAN PROPAGATE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.