2001 Ford Windstar engine and engine cooling problems

“I AM THE ORIGINAL OWNER OF THIS 2001 FORD WINDSTAR SE MINIVAN WHICH NOW HAS A RUSTED, CORRODED AND BROKEN PASSENGER SIDE ENGINE SUBFRAME WHICH RENDERS THE VEHICLE UNSAFE TO DRIVE. I COMPLIED WITH THE EARLIER FORD RECALLS WITH REGARD TO THIS ISSUE (11S16) AND THE SERVICE WAS COMPLETED (6/20/2012) AT THE FORD DEALERSHIP. NOW AFTER 27 MONTHS AND LESS THAN 16,000 MILES LATER, THE ENGINE SUBFRAME BREAKS AND THE COST TO REPAIR OF ABOUT $5,000.00 EXCEEDS THE KELLEY BLUE BOOK VALUES FOR THE VEHICLE. FORD HAS REFUSED ANY HELP AND CLAIMS THEY HAVE COMPLIED WITH THE RECALL WORK AND THE MATTER IS CLOSED. I BELIEVE THE RECALL SUPPORT BRACKET THAT WAS INSTALLED WAS NOTHING MORE THAT A BAND-AID APPROACH TO CORRECT A MAJOR SAFETY ISSUE WITH SUBSTANDARD ENGINE SUBFRAME PARTS. I HAVE ASKED FORD TO BUY MY VEHICLE BACK, AS THAT WAS AN OPTION UNDER THE RECALL(11S16) BUT THEY HAVE REFUSED AGAIN SAYING THE MATTER WAS CLOSED. IT SEEMS TO ME THAT THE ENGINE SUBFRAME PARTS SHOULD LAST MUCH LONGER THAN 13 YEARS OR 97,000 MILES. AFTER ALL FORD SUGGESTS THE 1ST ENGINE TUNE UP FOR THIS VEHICLE AT 100,000 MILES. I GUESS I WON'T BE WORRYING ABOUT THAT IN THE FUTURE. I HAVE THIS VEHICLE NOW…”

“WHILE INVESTIGATING THE 50 MPH FAILURE OF THE PCM MODULE, AND THE ONGOING OFF/ON ACTION OF THE ABS MODULE, I RAN ACROSS WHAT APPEARS TO BE A MISTAKE ON PAGE 43-3 OF THE FOMOCO "2001 WIRING DIAGRAMS/WINDSTAR" MANUAL (FCS-12255-01). I EXCHANGED SEVERAL EMAILS, CASE # CAS-4648613-L1X1R6 CRM:03259000003405, WITH THE FORD CUSTOMER RELATIONS CENTER ABOUT THIS MATTER UNTIL THEY TOLD ME TO CONTACT A DEALER. I SENT THE QUESTIONS TO MY DEALER ASKING FOR CORRECT INFORMATION, BUT THEY HAVEN'T ACKNOWLEDGED MY INQUIRY. WHAT I SUSPECT IS ALL WINDSTAR'S ON THE ROAD TODAY MAY BE OPERATING WITH ONLY ONE-HALF OF THE SCP (J1850 PWM) NETWORK OPERATIONAL. NOW THAT MANY OF THE DEFECTIVE ABS MODULES ARE FAILING, ARE OTHER WINDSTARS IN DANGER OF ENGINE FAILURE AT SPEED LIKE OURS? THE TWO SIMPLE QUESTIONS I ASKED FOMOCO ARE: 1) ARE YOU SURE CIRCUIT 915 (DATA BUS-) SHOULD BE GROUNDED AT THE ABS MODULE? 2) WHAT IS THE PROPER TERMINATION FOR THE FORD DATA BUS (CIRCUITS 914& 915), 120 OHMS, 650 OHMS, 3K OHMS, WHAT AND WHERE?”

“ALL PARTS ARE AFFECTED, MY CAR WHICH IS FORD WINDSTAR 2001 , IT GOT FIRED BY ITSELF AT EARLY MORNINGS WHILE IT WAS PARKED AND IGNITION WAS OFF, WE ARE THE VICTIM OF THE FORD WINDSTAR 2001,MY CAR IS TOTALLY BURNED. *TR”

“7/21/2011 BOUGHT VAN FROM PRIVATE PARTY. RECALL COMPLETED IN MARCH OF 2011 REGARDING BACK AXLE. ON 7/13/2012 8PM, MY 18YR OLD SON, WHILE DRIVING HOME FROM LACROSSE PRACTICE, NEARLY KILLED. UPON PULLING OUT ONTO THE MAIN ROAD, HE LOST ALL CONTROLS, NO STEERING, NO BRAKES AND NO POWER. HE COASTED AND PRAYED IT WOULD STOP. I ARRIVED, WE CALLED AAA. FLATBED TO MY HOME DRIVER COULD NOT BELIEVE HIS EYES. THE ENGINE HAD FALLEN OUT. 7/16/12 CALLED FORD IN MICH AND SPOKE TO REP. TO BE TOWED 13 MILES AWAY TO ROUTE 23 AUTO AT OUR EXPENSE. REALLY? ROUTE23 WANTED NOTHING TO DO WITH ME (THEY DID RECALL). WENT BACK AND FORTH THEN PER RT23 "IT WILL BE A MONTH UNTIL WE CAN LOOK AT IT" GETTING KNOW WHERE. 7/18-22 BORROWED FRIEND CAR FOR TOURNAMENT. 8/1/12 CALLED MAGARINO FORD AND WITH GREAT CONCERN HAD A FLATBED THAT NIGHT. THIS TOW TRUCK DRIVER COULD NOT BELIEVE IT. FLUIDS RACED OUT AND DOUBLE STABILIZED FOR ENGINE SLIDING DURING TRANSPORT. 8/2/12 MAGARINO CALLED 9AM, PICTURES SENT TO FORD AND AWAITING REPLY. 8/5/12 T/C FROM M STATING FORD REFUSES TO BUY BACK AND SENDING A SUBFRAME. YOU MEAN A RECALLED ONE? MAGARINO CAUGHT IN MIDDLE I QUESTIONED WHETHER HE WOULD PUT HIS…”

“THE ENGINE CRADLE WAS SEVERELY RUSTED AND HAD A CATASTROPHIC FAILURE. I NARROWLY AVOIDED GETTING T BONED AND CRASHED HEAD FIRST INTO A SMALL HILL. MY FIANCE AND MY SELF WERE UNINJURED BUT WHERE EXTREMELY SHOOK UP OVER THIS. I LOST ALL CONTROL OF THE STEERING AND THE ENTIRE ENGINE AND TRANSMISSION WHERE ON THE GROUND. THANKS TO THIS DEFECT IN FORDS DESIGN I AM NOW WITHOUT A CAR AND EITHER MY FIANCE OR MYSELF COULD HAVE BEEN BADLY INJURED OR DIED. *TR”

“THERE HAVE BEEN NUMEROUS ISSUES WITH THIS VEHICLE LATELY. CAR WOULD NOT START, POWER STEERING WENT OUT, OIL LIGHT STAYS ON, I HAVE TO PUT OIL IN EVERY WEEK, SEAT MOTOR STOP WORKING AND NOW THE BRAKES DO NOT WORK. WE WERE DRIVING OUT OF TOWN WITH OUR 3 KIDS AND I WENT TO PRESS THE BRAKES JUST TO FIND THAT IT WAS NOT THERE - IT WAS ALL THE WAY UP UNDER THE DASH BOARD!!!”