2016 Kia Optima engine problems

“Severe engine defect (Theta II 2.4L GDI). Sudden total loss of power, metallic knocking, severe oil consumption, and imminent catastrophic failure while driving, creating a high safety risk. Vehicle is currently out of service in [XXX].”

“The contact owns a 2016 Kia Optima. The contact stated that while driving 25 MPH, the vehicle shut off without warning. Soon after the failure, the engine caught fire; however, the fire dissipated independently. The insurance agent was contacted and arrived at the scene to inspect the vehicle. The contact was initially informed that the vehicle was safe to drive; however, the engine failed to start after several attempts. Due to the failure, the vehicle was towed to a dealer where a mechanic discovered that the knock sensor was inoperable and had caused the fire. The contact was informed that the vehicle was included in NHTSA Campaign Number: 18V907000 (Fuel System, Gasoline, Engine) and the vehicle was repaired under the recall. Nearly a month after the repair, the vehicle started consuming oil with the master warning light displayed. The vehicle was taken back to the dealer for an inspection; however, no fault was found with the vehicle. The manufacturer was notified of the failure, and the contact was referred to the dealer. After another inspection, the dealer agreed to replace the engine; however, the failure recurred after the repair.”

“While driving at highway speeds on the freeway in San Diego, the engine of my 2016 Kia Optima catastrophically seized without warning. I instantly lost all power steering, brake assist, and electrical power, creating an immediate life-threatening emergency. The vehicle was towed to a Kia dealer. Corporate Techline and the dealership are refusing to perform the mandated settlement rod bearing test and are falsifying paperwork to deny the safety remedy.”

“The engine assembly completely seized and the vehicle is currently stored at an independent repair shop . While traveling at high speed on Interstate 4 on July 24, 2026, the vehicle suffered a sudden, catastrophic loss of power and stalled in live traffic, creating an immediate threat of a high speed rear end collision. An independent service center officially confirmed the engine seizure after a dealership failed to perform an inspection during an eight hour wait, and no law enforcement or insurance inspections have occurred. Prior symptoms included severe, recurring oil loss requiring constant manual additions of oil between regular service intervals (most recently serviced in June 2026 at a kia dealership), and eventually the car completely shutoff on July24.”

“engine failure, i was driving home from work and i went to accelerate from 0 to 20 miles and the car hesitated and didn't want to move. I took the car to the dealer three days later and it was confirmed that i needed a new engine. I was told by the dealership i was outside of my warranty but i just found out that i was covered up to 120k miles. No lights came on at the time and there wasn't any prior warnings to this happening. I had just put oil into the car two days earlier as i know in between oil changes that i have to put oil into the car and or check the oil to see if it is low.”

“the engine. I was at a stop sign when the car stop responding to me pressing the accelerator and would not go. Upon further inspection it was noted that my car had no oil in it. I am diligent in getting my oil changed every 3 months or 3,000 miles. My engine had "seized" and i am being advised to purchase a new engine or purchase a new car. While trying to get my car to acclerate i was almost hit 4 times in a matter of 10 mins.”