2012 Kia Sorento fuel/propulsion system problems

“While driving I smelled gas, a few minutes later I saw smoke coming from the hood of the car. I stopped, turned the car off, got my dog, exited the car, which then exploded into flames. I saw that I was not safe the minute I saw the smoke. I was unsure that the gas smell was coming from my car until I saw that my gas needle was on E when I had filled up 3 hours prior. The police and the fire department was on scene. No warnings came up on the dash board other than the gas light.”

“On June 6, 2026, while driving home, the vehicle suddenly began smelling strongly of gasoline and burnt rubber. Within seconds, thick black smoke became visible in the side mirrors, followed immediately by white smoke pouring from the front hood and into the passenger cabin through the air vents. ​As I attempted to pull over to safety, the vehicle completely stopped responding. The brakes failed to operate, the engine stalled, and the steering wheel locked completely. We were barely able to bring the vehicle to a stop. Immediately upon exiting, visible flames erupted from underneath the driver's side of the vehicle and out of the front hood. The engine compartment and motor burnt completely.The safety of the driver and front passenger was put at extreme risk of death or severe injury. Because the brakes and steering locked up simultaneously while the cabin filled with smoke, we almost lost the ability to safely exit a moving vehicle that was actively catching fire. Furthermore, at no moment prior to or during the failure did any warning lamps, check engine lights, or diagnostic messages illuminate on the dashboard. There was absolutely zero advance warning from…”

“I smelled fuel in & around vehicle. Did some checking discovered cracked fuel rail , causing significant fuel leak when engine is on. Did some more research online discovered 2012 KIA Sedona recall SC188 “fuel rail leak” Identical issue my 2012 Sorento has but my VIN does not come up with fuel leak recall. There is however recall 23V652 HECU replacement- engine fire possible”

“On August 23rd 2024, I drove this vehicle all day. But, upon reaching our final destination (ER department entrance) smoke began rolling out from under the hood. Once getting out to inspection the vehicle someone hollered for a extinguisher. I turned to look at the vehicle and I could see underneath of the 2012 kia sorento had flames. My son was still in the car so my mother and I ran to get him out of his rear facing carseat and ran away from the vehicle. At this time the vehicle still had a fire that went out with extinguisher but quickly light back up. After this the whole are and car filled with smoke. Fire department was called and this took them awhile to fully extinguish the fire. This could have hurt myself, my child, and my mother. I lost alot of valuable things including my son's new carseat, my children's double stroller, a tablet, clothing, etc. I have called Kia as I found out there was a recall that kia has none about and started sending notices out November 14th 2023. My vehicle sat at a kia dealership from January to March 6th and if this recall was so drastic such as a car fire why was this not taken car of when my vehicle sat for 2 months. I…”

“While driving, the RPMS go to zero and the car stops and I lose all power. Yes, it's a safety risk to me and other drivers because it shuts off while driving. Someone following behind me can run into me. Yes, I took it to Ourisman Kia of Catonsville twice - They reproduced it happening the 2nd time I dropped it off after showing them a video of what happens. They said they don't know how to fix it. No, the vehicle was only inspected by the dealer. See video attached regarding warning lamps/messages etc.”

“My 2012 Kia Sorento has a recall for the motor, and I had taken it to Kia for an inspection and the dealer stated to me that my car does not have a recall on it. Recently my car stalled on the road while I was driving, and it nearly caused an accident because someone behind me had to break suddenly to stop.”