2004 Nissan Quest service brakes, hydraulic problems

“VEHICLE COMING OFF TURNPIKE ENTERING ONTO THE INTERSTATE WOULD NOT ACCELERATE PAST 45 MPH ONTO THE INTERSTATE ALMOST RAN OVER BY VEHICLES WHEN I WAS COMING OFF THE RAMP. VERY DANGEROUS. MANAGED TO GET VAN TO A SAFE PLACE WHERE WE HAD IT TOWED TO OUR HOME. WE HAD OUR MECHANIC LOOK AT IT AND HE DIAGNOSED IT AS THE TIMING CHAIN TENSIONERS NEEDED REPLACING AND IT HAD JUMPED TIME. HE WOULD NOT TOUCH IT SINCE THIS IS A KNOWN PROBLEM AND THERE IS A TECHNICAL SERVICE BULLETIN ISSUED FOR THIS YEAR VAN CONCERNING THE TENSIONERS. HAD IT THEN TOWED TO NISSAN AND THEY QUOTED 1700 TO FIX THE MECHANIC EVEN STATED THAT IT IS A HUGE PROBLEM AND HE IS SEEING AT LEAST 1 A WEEK WITH THIS VERY SAME ISSUE. BUT NISSAN WONT ISSUE A RECALL. IS IT GOING TO TAKE SOME FATALITIES FOR THEM TO WAKE UP AND REALIZE THIS IS SERIOUS. AFTER WORK PERFORMED TO VAN THEY CALLED AND SAID IT IS STILL MISFIRING THAT THEY FOUND VALVE COVER LEAKING OIL ON SPARK PLUGS ANOTHER 600 DOLLARS TO FIX THIS. I JUST REPLACED SPARK PLUGS IN 2010. ALSO REPLACED BRAKES 3 TIMES AND TIRES 2 TIMES NOW. ALTERNATOR ALSO REPLACED. I BOUGHT THIS VAN HOPING IT WOULD BE A SAFE AND RELIABLE VAN FOR MY FAMILY TO ENJOY FOR A LONG…”

“TL* THE CONTACT OWNS A 2004 NISSAN QUEST. THE CONTACT STATED THAT THERE WAS A RUMBLING NOISE COMING FROM THE REAR PASSENGER SIDE OF THE VEHICLE. THE CONTACT ALSO STATED THAT ALL OF THE LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE ABS ACTUATOR NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 136,000.”

“1). TRANSMISSION - 29,889 MI. TO PRESENT. SERVICED 6 TIMES. CONSTANTLY SHIFTS UP AND DOWN AT SCHOOL ZONE SPEED, LOUD CLUNK WHEN DECELERATING AT 40 MPH, LOUD CLUNK WHEN DECELERATING IN HIGHWAY EXIT CURVE. DEALER SAYS EVERYTHING IS WORKING TO SPECS...NOTHING FIXED. 2). BRAKES - 46,363 & 55,204 MI. NEW FRONT AND REAR BRAKES INSTALLED. AT 73,014 MILES VAN NEEDS NEW BRAKES AND ROTORS. 26,651 HIGHWAY MILES. WALLACE NISSAN SERVICE SAID NISSAN USED UNDERSIZED ROTORS FOR VEHICLE WEIGHT AND TIRE SIZE, HENCE NEED FOR FREQUENT REPLACEMENTS. 3). ELECTRICAL - 04/05/2010, 64,194 MI. THE VDC AND CK ENGINE LIGHTS CAME ON, VAN SPEED VERY ERRATIC...5 TO 40MPH ALL BY ITSELF, STALLED SEVERAL TIMES. DEALER COMPUTER DIAGNOSIS...FAULTY SENSORS IN CRANKSHAFT AND CAMSHAFT $209.07. 10/03/2011, 72,547 MI. SAME VDC AND ERRATIC SPEED. DEALER'S INITIAL DIAGNOSIS, FAULTY THROTTLE SENSOR, INSTALLED NEW SENSOR...SAME PROBLEM, UPON FURTHER INVESTIGATION DEALER FOUND THE ECM UNIT WAS TOTALLY CORRODED AND HAD TO BE REPLACED. $962.16. NISSAN MECHANICS SAY IT WAS A FAULTY DESIGN LOCATION OF THE ECM RIGHT UNDER THE WINDSHIELD WIPER COWLING WHICH ALLOWED WATER TO ENTER THE ECM, CORRODE IT AND CAUSE…”

“TL* THE CONTACT OWNS A 2004 NISSAN QUEST. THE CONTACT STATED THE SLIP WARNING LIGHT ILLUMINATED, CAUSING THE BRAKES TO FAIL WHEN APPLIED. THE CONTACT HAD TO CONSTANTLY PUMP THE BRAKES IN ORDER FOR THE VEHICLE TO DECELERATE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THEY INSPECTED THE LINES AND THE BRAKES BUT COULD NOT FIND ANY FAILURES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 107,081.”

“BAD VIBRATION WHEN BRAKING, CHANGED ROTORS AND PADS ON FRONT BRAKES SEEM TO MAKE THE PROBLEM LESS BUT AFTER A PERIOD OF TIME A CLUNKING NOISE 5000 MILES WAS STARTING TO BE HEARD. CONTROL ARM BALL JOINT ON RIGHT SIDE HAD EXCESSIVE PLAY AND WAS REPLACED, BUT THAT DID NOT GET RIDE OF THE SHUDDER IN THE BRAKING SITUATION. TOLD IT WAS WARPED BRAKES, REPLACED BREAK ROTORS AND PADS 1000 MILES . STILL NO DIFFERENCE IN THE SHUDDER IS STILL THERE ROTATED THE TIRES NO DIFFERENCE IN THE SHUDDER. I HAD NEW TIRES IN THE CAR WHEN THE RIGHT FRONT WHEEL FELL OFF. NO STUD-LUGS COULD BE FOUND AND MAJOR DAMAGE TO FRONT FENDER AND BUMPER. OUR AU PAIR DRIVER REPORTED A NOISE COMING FROM SOMEWHERE BUT VISUAL INSPECTION DID NOT INDICATE WHERE THE PROBLEM WAS. CONTINUED TO DRIVE WHEN THE NOISE BECAME LOUDER PULL OFF INTERSTATE TO SHOULDER AT ABOUT 15 MPH TILE FELL OFF. BODY AND MECHANICAL WORK WILL BE DONE. TO CORRECT THE PROBLEM. *TR”

“WHENEVER WE HIT THE BRAKES OUR 2004 NISSAN QUEST SHUTTERS AND SHAKES. WE FIRST REPORTED THE PROBLEM AT ABOUT 23,000 MILES. VAN HAS BEEN TO THE DEALER AT LEAST 5 TIMES FOR THIS PROBLEM. MECHANIC CAN NEVER FIND ANYTHING WRONG. ON OUR OWN WE HAVE REPLACED THE FRONT ROTORS WHEN IT WAS DISCOVERED BOTH ORIGINAL ROTORS HAD WARPED, REPLACED THE BRAKE PADS THREE TIMES, AND TURNED THE ROTORS 6 MONTHS AFTER REPLACING THEM (79K MILES). VAN GOES BACK INTO THE DEALER NEXT WEEK AGAIN TO HAVE THE PROBLEM ADDRESSED AGAIN AS IT HAS GOTTEN WORSE. I AM STATIONED WITH THE MILITARY AWAY FROM HOME, AND MY WIFE USES THE QUEST AS HER ONLY TRANSPORTATION WITH OUR TODDLERS, OLDER CHILDREN, AND GUESTS. VAN NOW HAS 114K MILES. *TR”