2022 Nissan Rogue power train problems

“An authorized Nissan franchise executed an active safety recall campaign on my vehicle regarding coolant loss. Technicians failed to secure critical powertrain components during reassembly. Three days post-delivery, a major engine bolt fell out on the highway and the chassis began vibrating violently. A certified military base auto hobby shop inspection officially grounded the vehicle, finding a broken rear motor mount bracket, unfastened structural bolts, and a completely disconnected transmission/engine hose left by the franchise. This constitutes a severe post-recall safety failure that actively endangered my family on public roads.”

“On [XXX], my 2022 Nissan Rogue (1.5L VC-Turbo, about 66,000 miles) suddenly lost power while being driven near Lehighton, PA. The check engine light came on, the vehicle would not respond to the accelerator, the oil pressure warning came on, and the engine stalled. We had to get to the side of the road with no power, which put us and surrounding traffic at risk. The vehicle could not be driven and was towed 128 miles to a Nissan dealer. The Nissan dealer confirmed the failure. Their master technician found coolant getting past the valves into the engine cylinders. Nissan then stated that the EGR cooler failed, allowing coolant into the engine and causing it to overheat. The engine must be replaced. Nissan declined to cover the repair, stating the EGR cooler is not covered under its extended engine warranty. A third-party inspector for the vehicle’s service contract is expected to examine the vehicle. The dealer has been asked to retain the failed EGR cooler for inspection. This vehicle is included in recall 25V-437 (engine bearings). The recall remedy (Nissan campaign R25D1: ECM reprogram and engine check) was completed by a Nissan dealer on [XXX], at about…”

“The EGR Cooler failed and caused a significant coolant leak into my engine. Causing sudden engine failure while driving. I experienced sudden power loss, loss of throttle control due to the motor being placed in the "safety mode" due to the engine coding, and was only able to drive on the shoulder of the road at ~25MPH, causing traffic disruptions until I was able to safely exit the roadway. I was able to get the vehicle diagnosed by Nissan, it resulted in over $10000 of repairs to fix the damage. The vehicle has less than 80000 miles and is still covered under extended warranty. However, Nissan rejected the repair claim due to it being the EGR cooler that failed.”

“My 2022 Nissan Rogue 1.5L VC-Turbo is experiencing repeated limp-mode/reduced-power events, severe hesitation, poor acceleration, rough/shaking idle, and recurring DTC U0652 after Nissan marked recall 25V-437 complete. The vehicle is available for inspection. Reduced-power symptoms were documented as early as Dec. 2024 and significantly worsened by Oct. 3, 2025 at approximately 100,400 miles, including loss of power at highway speed. I previously reported this condition to NHTSA under Complaint #11696068. The first Nissan dealer (Willis) used a borescope, claimed “sludge,” recommended engine replacement, refused to provide supporting photos/evidence, and did not remove the oil pan. Willis later provided me an oil sample, which I submitted for independent analysis. That analysis showed multiple bearing-associated wear metals without an abnormal viscosity condition explaining the findings, and confirmed the oil pan was had not been checked. A second Nissan dealer was contacted to performed Nissan’s recall screening/software procedure. No engine light could be on upon arrival. Because the intermittent condition did not occur during the brief test, Nissan marked…”

“My 2022 Nissan Rogue has entered reduced-power/limp mode approximately nine times. The specific component causing the malfunction has not been identified. The vehicle is available for inspection upon request. When the malfunction occurs, the vehicle displays a malfunction/reduced-power warning and substantially reduces available engine power. Several occurrences happened during a long-distance trip involving highway, mountain, and desert driving. The unexpected reduction in power creates a safety concern during highway travel, merging, passing, climbing grades, or travel in remote areas. The problem is intermittent and has not been successfully reproduced by an authorized Nissan dealership. I presented the vehicle to a Nissan dealer and reported the repeated events while the vehicle had approximately 56,500 miles and remained below Nissan's 60,000-mile powertrain warranty mileage limit. The dealership advised that it could not diagnose the problem unless the malfunction occurs again with an active diagnostic code. I have also reported the problem to Nissan Consumer Affairs. The underlying cause remains unidentified and the vehicle has not been repaired for this…”

“The contact owns a 2022 Nissan Rogue. The contact stated that while driving at various speeds, the transmission unexpectedly downshifted with the messages "Engine Malfunction Power Reduced Service Now" and "AWD Error Malfunction" displayed on the instrument panel. Following the failures, the vehicle failed to accelerate above 15 MPH after being restarted. The vehicle was towed to the dealer on several occasions. The contact stated that after a software update, a coolant bypass repair, and an engine flush, the failure persisted. The manufacturer was notified of the failure, and a case was opened. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 53,370.”