2015 Ram 1500 electrical system problems

“I was traveling northbound on [XXX], just before [XXX], at approximately 35 mph on dry asphalt in my 2015 Ram 1500 3.0L EcoDiesel just after refilling the fuel tank with 13.999 gal. of diesel fuel. While the vehicle was being driven both fuel-tank retention straps broke. The fuel tank dropped from its retained position and was observed resting on the asphalt beneath the vehicle. The vehicle lost all power causing a near-miss incident while attempting to navigate out of traffic. After coming to a stop, the vehicle was moved to the side of the road and parked just east of [XXX] on [XXX]. Passenger and eyewitness [XXX] experienced the entire incident and also observed the fuel tank beneath the vehicle and the broken straps. The vehicle could crank but would not start; and the fuel lines and electrical supply were both damaged. The check-engine light illuminated, as well as the fuel low and fuel sensor fail messages occurred during and after the incident. AAA towed the vehicle directly to Byers Chrysler Jeep Dodge Ram on XXX. Dealer repair order XXX was opened XXX, and the vehicle was physically inspected on XXX. The dealer documented: “VERIFIED CUSTOMER CONCERN.…”

“Subject: Safety Defect – 2015 Ram 1500 – ABS Module Failure, Part Discontinued, No Recall Vehicle: 2015 Ram 1500, 5.7L VIN: [XXX] Mileage: 65000 Date of failure: May 2022 I am writing to report a safety-related defect on my 2015 Ram 1500 and to formally request corrective action. Description of the problem: The Anti-lock Braking System (ABS) module (Mopar part number 68228991AD) on my vehicle has failed. As a result, the ABS and Electronic Stability Control (ESC) systems are completely inoperative, as indicated by persistent warning lights on the instrument cluster. This significantly compromises the vehicle's braking and stability performance, particularly in wet or emergency conditions, and renders the vehicle non-compliant with federal safety standards (FMVSS 135 – Anti-lock Braking Systems). Part unavailability: The required replacement module (68228991AD) or 68228991AE , is discontinued or in backorder for years and is currently in an "engineering hold" status at the factory. Dealerships are unable to order or procure the part. There is no estimated time of availability, no interim repair procedure, and no software workaround. The vehicle is non-operable…”

“ABS module failure. Warning lights on dash- ABS lamp (code C2200), traction control lamp, service trailer brake system message, and red brake fault lamp illuminated. Does not go away after vehicle running. Reduced braking feel present. Will not pass state inspection for legal road use due to red brake lamp on status, no abs module replacements from dealer- national backorder with unknown shipping date currently.”

“Odometer Fraud. The contact purchased a 2015 Ram 1500. The contact stated that after purchasing the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was purchased at the local independent dealer with an odometer reading of 141,356. Later, after obtaining a Carfax report, the mileage listed on the vehicle was 230,229.”

“Abs module goes out which shuts off abs, traction control, and cruise control, and you can’t get the part anywhere except for third party refurbished. In Pennsylvania I can’t get inspection when red warning brake light is on.”

“On July 2nd, I was actively driving my 2015 Ram 1500 equipped with the 5.7L Hemi V8 gas engine. The vehicle is completely factory-stock with zero aftermarket electronics, wiring modifications, or accessories. While operating the truck, the dashboard instrument cluster suddenly began flickering wildly, indicating a severe voltage drop or electrical system failure. Immediately following the flickering, a catastrophic fire erupted inside the cabin, originating directly underneath the dashboard on the passenger's side. The fire department responded to extinguish the flames. The engine bay was unaffected by fluid leaks, and the fire originated strictly within the factory dashboard electrical wiring harness/modules. The vehicle is a total loss.”