NHTSA lists 2 safety recalls and 177 owner complaints for the 2002 Saturn Vue. Most complaints involve electrical system (52) and engine and engine cooling (32). The EPA rates it 19–22 mpg combined.
General Motors LLC (GM) is recalling certain model year 2002-2004 Saturn Vue vehicles manufactured September 11, 2001, to April 6, 2004. In the affected vehicles, it may be possible for the key to be removed from the ignition when the ignition is not in the "Off" position.
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." SOME VEHICLES WERE PRODUCED WITH REAR OUTER SEAT BELT SHOULDER GUIDE ANCHOR BOLTS THAT WERE INCORRECTLY INSTALLED.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“CAR POWER SHUTS DOWN WHILE DRIVING, UNABLE TO START AGAIN IN ANY TRAFFIC OR ROAD CONDITIONS TO MOVE CAR TO A SAFE AREA. FULL LOSS OF POWER UNEXPECTED, VEHICLE SIMPLY STOPS RUNNING. THIS VEHICLE WAS PURCHASED 'USED' FROM A PRIVATE SELLER I SUSPECT WAS WELL AWARE OF THE SITUATION BUT DIDN'T EXPOSE IT. $2300 SPENT SO FAR WITH NO FINDINGS AS TO WHY THE PROBLEM OCCURS. ONLY AN ADDED 30 MILES TO THE ODOMETER SINCE PURCHASE. PRESENT READING IS 107,251.”
“I'M THE ORIGINAL OWNER OF A 2002 SATURN VUE AWD WITH THE GM VTI TRANSMISSION AND ENGINE. TWO DAYS AGO I EXPERIENCED MY TRANSMISSION/ENGINE FAILING FOR THE FIFTH OR SIXTH TIME SINCE 2006. THE VERY FIRST TIME I TOOK MY VUE TO THE DEALERSHIP IN AUSTIN, TX WHERE I HAD TO ARGUE WITH FIRST MY SERVICE REP. FOLLOWED BY HIS MANAGER THAT THE PROBLEM WAS WITH THE TRANSMISSION. SINCE THE FAULTY GM DESIGN WAS STILL RELATIVELY NEW, THEY ORIGINALLY BLAMED ME FOR POOR DRIVING, RESULTING A BAD BCM WHICH THEY MADE ME PAY IN SPITE OF MY ARGUMENT THE FAULTY GM DESIGN WAS THE ORIGIN OF THE PROBLEM. FIRST TIME IT COST ME $1500 TO REPAIR MY CAR THAT HAD LESS THAN 60,000 MILES ON IT. THIS HOWEVER WAS QUITE AN ORDEAL SINCE MY VEHICLE ACTUALLY LOST POWER ON THREE OR FOUR DIFFERENT OCCASIONS. I WOULD IMMEDIATELY GO TO THE DEALERSHIP FOR ASSISTANCE WITH WHAT I KNEW WAS THE TRANSMISSION. AFTER BUGGING THEM ALMOST EVERYDAY WITH THE SAME PROBLEM THEY FINALLY ADMITTED GMS TRANSMISSION PROBLEMS AND REPLACED MY TRANSMISSION ON THE THIRD VISIT. THE SECOND TRANSMISSION LASTED APPROXIMATELY A YEAR. IN 2007 I HAD RELOCATED WITHIN THE STATE AND WAS EXPERIENCING SIMILAR PROBLEMS AND RELUCTANTLY…”
“THE TIMING CHAIN RUINED THE ENTIRE ENGINE AS A RESULT OF THE CHAIN TENSIONER FAILING FROM LACK OF OIL BEING APPLIED. APPARENTLY AS SOON AS I HEARD THE CLANGING SOUNDS IT WAS TOO LATE. I AM BUYING A WHOLE NEW ENGINE WHICH HAS REPLACED THE OILING MECHANISM THAT WAS FAULTY IN THE 2002-2003 MODELS OF THE SATURN VUE. *TR”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Vue FWD Auto (variable gear ratios), 4 cyl, 2.2 L · Front-Wheel Drive | 19 | 26 | 22 | $2,900 | 404 |
| Vue FWD Man 5-spd, 4 cyl, 2.2 L · Front-Wheel Drive | 20 | 26 | 22 | $2,900 | 404 |
| Vue AWD Auto (variable gear ratios), 4 cyl, 2.2 L · 4-Wheel or All-Wheel Drive | 18 | 24 | 21 | $3,050 | 423 |
| Vue AWD Auto 4-spd, 6 cyl, 3.0 L · 4-Wheel or All-Wheel Drive | 17 | 23 | 19 | $3,400 | 468 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
2 safety recalls as of Oct 27, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 177 complaints with NHTSA. The most-cited components are electrical system (52), engine and engine cooling (32), power train (28). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2002 Saturn Vue at 19–22 mpg combined, depending on engine and drivetrain (4 versions rated).