NHTSA lists 4 safety recalls and 53 owner complaints for the 2002 Suzuki Grand Vitara. Most complaints involve vehicle speed control (16) and service brakes, hydraulic (11). The EPA rates it 17–18 mpg combined.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
ON CERTAIN PASSENGER VEHICLES, UNDER AMBIENT TEMPERATURES BELOW -25 DEGREES CELSIUS, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. AS A RESULT, FUEL SYSTEM PRESSURE MAY INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“TL* THE CONTACT OWNS A 2002 SUZUKI GRAND VITARA. THE CONTACT STATED THAT WHEN AT A STOP WITH HER FOOT ON THE BRAKE PEDAL, THE VEHICLE'S ENGINE WOULD BEGIN TO REV WITH THE RPM LEVELS VIGOROUSLY FLUCTUATING. SHE NOTICED THE PROBLEM ON THREE DIFFERENT OCCASIONS SINCE JUNE 2009. SHE TOOK THE VEHICLE TO THE DEALERSHIP AND THE DEALER STATED THAT THEY COULD NOT FIND A CAUSE FOR THE FAILURES. SHE CALLED THE MANUFACTURER AND WAS INSTRUCTED TO TAKE THE VEHICLE TO THE DEALERSHIP. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 59,330. THE FAILURE MILEAGE WAS APPROXIMATELY 54,000.”
“DT: THE CONSUMER STATED THERE WAS A LOUD POPPING SOUND WHILE DRIVING AT 35-40 MPH. THIS HAPPENED WITHOUT WARNING AND NO PREVIOUS PROBLEMS. THE CONSUMER INSPECTED THE VEHICLE BECAUSE SHE THOUGHT SHE MAY HAVE RUN OVER SOMETHING. THERE WAS NO EVIDENCE OF THIS, AND SHE PROCEEDED. AFTERWARDS, THE BRAKES WERE HARD TO APPLY. AGAIN THE POPPING NOISE BECAME MORE PROMINENT AFTER APPLYING BRAKE PRESSURE. THE CONSUMER INSPECTED THE VEHICLE AGAIN AND DISCOVERED NOTHING AT THAT TIME. THE POPPING NOISE CONTINUED ALONG WITH HARD BRAKING, AND THE VEHICLE WAS PULLING TO THE RIGHT IN WHICH THEY STATED THAT THE REAR BRAKES FAILED ALONG WITH THE STRUTS. THE ENTIRE HARDWARE INCLUDING THE SHOES AND THE DRUMS WERE DESTROYED. THE MECHANIC COULD NOT DIAGNOSE WHY THIS PROBLEM OCCURRED. THE VEHICLE WAS CURRENTLY IN THE SHOP FOR REPAIRS. *AK (11/23/05) THE CONSUMER WAS INFORMED THAT THE CABLES HAD BROKEN LOOSE AND THE REAR BRAKES COULD SELF DESTRUCT. *SC”
“GASOLINE FUEL DOOR FELL OFF FOR NO REASON, AS FAR I CAN TELL, ALL THE HARDWARE THAT WOULD SECURE FUEL DOOR IS STILL THERE. I HAVE SEEN OTHER SUZUKI'S WITH THE SAME THING. *JB”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Grand Vitara Auto 4-spd, 6 cyl, 2.5 L · Rear-Wheel Drive | 17 | 19 | 18 | $3,550 | 494 |
| Grand Vitara Man 5-spd, 6 cyl, 2.5 L · Rear-Wheel Drive | 17 | 20 | 18 | $3,550 | 494 |
| Grand Vitara 4WD Man 5-spd, 6 cyl, 2.5 L · 4-Wheel or All-Wheel Drive | 17 | 20 | 18 | $3,550 | 494 |
| Grand Vitara 4WD Auto 4-spd, 6 cyl, 2.5 L · 4-Wheel or All-Wheel Drive | 16 | 19 | 17 | $3,800 | 523 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
4 safety recalls as of Oct 29, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 53 complaints with NHTSA. The most-cited components are vehicle speed control (16), service brakes, hydraulic (11), fuel system, gasoline (7). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2002 Suzuki Grand Vitara at 17–18 mpg combined, depending on engine and drivetrain (4 versions rated).