2021 Tesla Model 3 steering problems

“2021 Tesla Model 3 with approximately 110,000 miles. Loud creaking/squeaking noise from the front suspension (primarily passenger side) when driving at low speeds over bumps and during slow turns. The noise matches the known front upper control arm ball joint water intrusion issue documented in Tesla service bulletin SB-20-31-006 and widely reported by other Model 3 owners. No warning lights, messages, or other symptoms. The component is available for inspection. I have scheduled a service appointment with Tesla but the vehicle has not yet been inspected or repaired by the manufacturer or any independent shop. While currently only a noise (NVH) issue, progressive wear of this ball joint can lead to play in the suspension, uneven tire wear, degraded steering feel, and potential loss of control if the joint fails.”

“I have a model 3 2021 Tesla. I noticed that several times it gives me the alert for steering wheel malfunction when it rains. In these instances the car will completely froze in the middle of the highway. I noticed Tesla had a recall for the 2023 Tesla’s for the same issue but failed to inspect the 2021 that also has similar issues. I think this is a huge safety issue that’s a manufactured issue that could have cost me my life”

“My steering suddenly got extremely stiff on the highway while driving. There was a warning that assist will be reduced but no assist was present. I had to use all my strength to turn the steering and pulled into a parking lot with great difficulty. Then I reset the main computer and the power steering was functional again. I was lucky since the traffic was moving slower than usual but it could have been very dangerous and was a major safety concern.”

“After Tesla replaced my high voltage battery in May of 2024 all of the following started to happen. Prior to the replacement none of these issues were present. While driving under normal conditions, my 2021 Tesla suddenly and violently steered into an oncoming lane or toward the roadside without any driver input. The steering wheel physically turned on its own with force. Full Self-Driving was NOT engaged at the time of the incident. This was not lane assist correction and occurred without warning. Importantly, the vehicle did NOT issue a warning at the time of the steering event. A “Take Control Immediately” message appeared several minutes AFTER the incident, not before or during, indicating a delayed or failed system response. This defect began immediately after a High-Voltage Battery replacement performed by Tesla Service in May 2024 and has occurred multiple times since. The incident presents a serious safety risk, including loss of vehicle control, roadway departure, or head-on collision. In addition to the steering defect, the vehicle began exhibiting multiple electronic and control anomalies immediately after the High-Voltage Battery replacement. These…”

“Steering rack failure. Steering assist, auto pilot and lane departure prevention failed and would not work properly so this is a safety issue. Manual steering worked fine but the safety and auto pilot functions would no longer function. Paid for Tesla service over $3,000 to replace steering rack and now is working properly. Reporting this as this may happen to others and probably should be a proactive recall on the steering racks so others don't lose these safety features. Maybe related to computer as it failed, worked again and then failed again and was then repaired by Tesla service center.”

“While driving a Tesla 2021 model 3 tonight at 8:45 P.M. turning left the wheels locked to the left and would not turn straight causing me to hit a concrete divider. After hitting concrete divider steering released to normal driving but driver side car front rim tire was damaged and wheel alignment misdirected.”