2007 Toyota FJ Cruiser problems

“The contact owns a 2007 Toyota FJ Cruiser. The contact stated that while her son was attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to an independent mechanic; however, no cause for the failure was found. The independent mechanic informed the contact that the undercarriage and subframe were severely corroded. The contact was informed that the vehicle should not be driven because the wheels might detach from the vehicle. The vehicle remained with the dealer unrepaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 185,000.”

“My fj cruiser has terrible rust on the frame. It literally looks like it was stored in the ocean for 50 years. This vehicle is from 2007 and should not have this much rust.”

“I WAS DRIVING APPROXIMATELY AT 30 MILES PER HOUR, IN A RESIDENTIAL STREET, WHEN SUDDENLY I HEARD A NOISE AND NOTED THAT THE WINDSHIELD DEVELOPED A FIVE INCH CRACK, STARTING FROM THE BOTTOM CENTER GOING UP. A FEW DAYS LATER, THE CRACK MOVED SIGNIFICANTLY, TO THE LEFT AND RIGHT OF THE WINDSHIELD MOVING TO COVER THE ENTIRE WINDSHIELD. THERE WAS NO PRIOR DAMAGE TO THE WINDSHIELD, THE VEHICLE HAS NEVER BEEN IN AN ACCIDENT AND IT HAS NEVER BEEN TAKEN OFF ROAD. THE CRACK SEEMS TO HAVE DEVELOPED DUE TO PRESSURE STRESS- A DEFECT FROM MANUFACTURING. THERE ARE NUMEROUS OTHER REPORTS FROM OTHER OWNERS OF THIS TYPE OF VEHICLE WITH SIMILAR REPORTS, OFTEN TIMES, EVEN AFTER HAVING THE WINDSHIELD REPLACED. THIS IS A SAFETY CONCERN AND MANUFACTURING ERROR.”

“The fj cruiser is a common issue for rot/ rust on the frame of the vehicle, I have clean the frame often during the winter months and my frame is continuously rusting and rotting the frame of the vehicle I have decided to not drive the vehicle till the frame is either replaced or repaired due to the safety concern of driving it on the road, numerous others have same incidents of the holes in the frame due to rust the manufacturer did not put any kind of corrosion treatment on the frame to stop this from happening the frame flexes when accelerating and is not safe for anyone to including my passengers or other people on the road”

“THE DRIVER'S LEFT FOOT REST CAME LOOSE AND WENT UNDER THE BRAKE PEDAL. I WAS ABLE TO CLEAR THE PEDAL BEFORE BRAKING. I THINK THIS COULD BE A WIDE-SPREAD ISSUE AFTER LOOKING AT SEVERAL INTERNET POSTS. *TR”

“I was driving down the street after filling up my fuel tank. I drove approximately 1/2 mile when I heard a sound, felt a clunk and stopped immediately. My fuel tank was hanging down on the ground. I called AAA and requested a flatbed and to bring a strap. He did not bring a strap and when my truck arrived at the mechanic the fuel tank had completely separated from the vehicle. The other complaint I have is the rusted frame. I purchased this vehicle used. I did not notice that the tube before the rear axle which holds suspension supports to the frame were completely broken off and separated from the rusted out frame that has failed. It has been welding but the rusted frame is very difficult to weld to.”