2024 Toyota Grand HighlanderRecalls, problems, MPG & safety

“Transmission Whining Noise Detected, Automatic Shifting Difficulties, Reduced Power & Acceleration Concerns. Dealer inspected and confirmed transmission failure. Required Dealer replacement under power train warranty. Defect known to exist in Toyota 6 speed Automatic U80A transmissions. Transmission is known to be defective and unreliable, potentially causing catostrophic injury to persons and property with use and operation.”

“The air conditioning system on my 2024 Grand Highlander failed due to a punctured AC condenser caused by road debris passing through the front grille during normal driving. The front fascia has large open apertures with no protective mesh or screening, leaving the condenser, radiator, and other heat exchangers directly exposed to rocks and debris. The condenser face shows multiple debris strikes, with one impact puncturing the core and causing complete refrigerant loss and AC failure at approximately 62,000 miles. The vehicle worked normally when parked and the AC was completely dead one week later due to the slow refrigerant leak from the puncture. Diagnosis was performed by [XXX] Toyota in [XXX], which confirmed the puncture was caused by road debris. The repair is not covered under warranty or my extended service contract because it is classified as outside damage, leaving owners to pay out of pocket for a design vulnerability. This is the same failure mode described in open ODI Defect Petition No. XXX covering 2024-2026 Grand Highlander vehicles. The same unprotected grille openings expose the engine radiator, meaning the identical debris path can puncture…”

“I own a 2024 Toyota Grand Highlander Hybrid MAX Platinum, purchased brand new in February 2024 and now with approximately 30,400 miles. Since the first few weeks, the vehicle has had an ongoing fuel tank/range issue. The fuel tank is rated at approximately 17 gallons, but the gas pump consistently shuts off after only 10–12 gallons, even when the vehicle indicates 0 miles to empty. It accepts approximately the same amount whether I refuel with 80, 20, or 0 miles remaining. After filling, the vehicle reports the tank as full and but generally shows only 270–290 miles of estimated range. The actual miles driven before requiring fill up is 230-250 miles. Toyota issued T-SB-0060-25 (Low Fuel Warning Light Logic Enhancement), which a Toyota dealer reluctantly performed on my vehicle. It initially improved the displayed range by only about 10 miles, but did not resolve the problem, and the condition is now worsening. The dealer solution was to tell me I can drive another 60-100 miles past empty but I do not believe that is a reasonable or safe workaround. This is because the driver cannot reliably determine the remaining usable fuel or how far the vehicle can safely…”