111 owner complaints to NHTSA about the 2004 Toyota Sienna cite vehicle speed control, 5% of all 2,062 complaints for this model year. NHTSA also lists 1 recall on this component.
“Vehicle often applies brakes on its own . At first it was only in turns . However now it does it when driving straight on the the freeway or just down the street at 45mph. I have fixed my alignment ,new tires, all of the front suspension and nothing prevents the car from trying to brake for me. it is a safety feature that is not safe at all. a car slamming on your brakes at any speed is dangerous in addition to that it seems to cut off your fuel , leaving you unable to accelerate until its done beeping which can take a long time. the vsc , chenk engine and trac off flash there is no crash to report I have been lucky so far”
“Was driving on highway at 60-65 mph. The car continued to accelerate. Pressed on brake and wasn't slowing the vehicle. The driver was weaving in and out of cars as the van started to creek up to 92 mph. The driver and passengers thought they were going to crash and possible die. The driver tried the brake multiple times and nothing. The driver said the accelerator pedal wasn't pressed all the way down to the floor. It was half way and driver had to go down and pull up on the pedal while driving. The van then started to slow and driver was able to pull over to have the van evaluated . The throttle body was reached and cleaned of carbon because it said that this may have been part of the issue. Never has this van taken off like this. The throttle body cable wasnt loose or disconnected either. So far we havent been able to recreate but 3 people could have been killed.”
“The contact owns a 2004 Toyota Sienna. The contact stated that while driving approximately 65 MPH the vehicle suddenly experienced unintended acceleration and the speed of the vehicle increased to over 90 MPH. During the failure, the braking system had failed and would not stop the vehicle while pressing the brake pedal. The front passenger was able to view the fuel pedal was stuck to the floor and was able to physically pull the fuel pedal up from the stuck position and the vehicle's speed was reduced. The incident lasted for approximately 10 minutes. During the incident, the police were on the scene. A police report was later filed at the scene and the vehicle was towed to the local dealer. The contact was informed by the dealer that the failure was due to a missing fuel pedal pen. No further information was available. The manufacturer was notified of the failure. The contact expressed experiencing emotional stress and anxiety during and after the incident. The manufacturer was notified of the failure. The failure mileage was 200,000. The VIN was not available.”
“- Traction control engaged at high speed(70 mph on interstate) causing the vehicle to brake abruptly and pull the vehicle to the right. Had I been traveling in the left hand lane, I could have been forced into the right hand lane causing a collusion with another vehicle. Also occurred at lower speed(30 mph on a windy road) causing the same issue as described above, almost causing the vehicle to leave the paved surface. - Mechanic was able to duplicate the issue - Mechanic diagnosed intermittent traction control activation, scanned computer for codes. Yaw rate/steering angle correlation causing false activation ABS/traction. Replaced hub bearing and spindle. Four wheel alignment, including check castor, camber and adjust toe. Performed zero point calibration and reset ABS memory. - Traction control lights up briefly”
“About a year ago the Vehicle Stability Control warning light along with an audible alarm started coming on intermittently while turning on highways going uphill or downhill in dry weather and with no risk of any tire slipping. At first this only happened at higher speeds 65+mph. Over time, it has occurred more and more frequently and can occur at speeds down to 25 mph. At times, the Anti-lock Braking System is also activated resulting in jerky braking and loss of throttle. When people have been following me too closely, this has almost caused accidents. When these symptoms occur, it is always on a curve (of any degree, even slight curves) and while driving at least 25 mph, and even happens on flat turns now. The weather has always been dry with no risk of tire slippage.”
“Sometimes when I take turns in my Sienna, the VSC starts going off and braking individual wheels without my control. This happens unexpectedly on highway bends at speeds of 60+ mph and it is difficult to control the car and keep from swerving into another lane. If the roads were icy when this happens, it would probably cause a dangerous accident. Toyota has a technical service bulletin for this, but not a recall - which it should since this is a significant safety issue. The TSB is BR008-04. There are many others experiencing this same issue: https://forums.edmunds.com/discussion/13855/toyota/sienna/vsc-sudden-activation-2004-toyota-sienna”
Showing 6 of 111 reports. Read every report on NHTSA.gov.
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 26,501 EARLY 2004 MY SIENNA VEHICLES. IN THE EVENT THE RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER IS MISSING, THE COVER CAN INTERFERE WITH THE OPERATION OF THE ACCELERATOR PEDAL IF THE ACCELERATION PEDAL IS DEPRESSED TO NEARLY THE FULL THROTTLE POSITION.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.