2016 Toyota Sienna problems

“The contact owned a 2016 Toyota Sienna. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 16V858000 (Structure); several years ago. The contact stated that the dealer only serviced the passenger’s side sliding door, even though the recall indicated that both doors were included. The contact stated that the driver’s side rear sliding door had not yet failed completely but was malfunctioning. While pressing the button, the power door closed but failed to latch or seal shut. The contact stated that closing the door manually worked properly. The dealer was notified of the issue but declined to assist and indicated that the repair had expired in July 2026. The failure mileage was 196,000.”

“TL* THE CONTACT OWNS A 2016 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE STOPPED WITH THE ENGINE STILL RUNNING, THE PASSENGER'S SIDE SLIDING DOOR SLID OPEN INDEPENDENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AUBURN TOYOTA (800 NEVADA ST, AUBURN, CA 95603) AND REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 16V858000 (STRUCTURE). APPROXIMATELY TWO YEARS LATER, THE FAILURE HAD RECURRED WHILE THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER ON TWO SEPARATE OCCASIONS WHERE THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE AND A CASE WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 36,512.”

“What component or system failed or malfunctioned, and is it available for inspection upon request? The engine/transmission and the vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? While driving the vehicle at the rate of 55-60 mph, the vehicle came to a complete/instant stop without warning — potential causing harm or even death to the occupants of the associated vehicle, and it adversely affected my ability to safely control the vehicle. Also, as the incident was occurring, my drivers seatbelt became very, very tight. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, but this is the second occurrence of this same incident within the past 30 days.”

“EXCESSIVE TIRE WEAR ON THE OUTSIDE OF THE FRONT WHEELS AFTER 20,000 MILES. MINIVAN IS DRIVEN IN NORMAL CITY AND HIGHWAY DRIVING. TIRES ARE ROTATED EVERY 5,000 MILES. ALL 4 TIRES WILL NEED TO BE REPLACED AFTER 20,000 MILES.”

“A deer was struck on the driver to middle of the front of the van while traveling 75 mph on the highway. Caused significant enough damage that van was inoperable. What was concerning was the airbags did not deploy despite the significant force and high speed associated with this accident.”

“The contact owns a 2016 Toyota Sienna. The contact stated that the driver’s side electric sliding door failed to properly open and close, and occasionally abruptly closed, causing a safety hazard to the occupants entering and exiting the vehicle. The cause of the failure has not yet been determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 16V858000 (STRUCTURE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was unknown.”