2004 Toyota Tacoma suspension problems

“I was turning into a gas station and all the sudden the vehicle came to a complete stop i was unable to move the vehicle and sat there until the tow truck was able to show up. Looked under the vehicle and on the passenger side front suspension the lower ball joint was no longer where it belongs.”

“The vehicle has an open recall (NHTSA Recall #12V542) for the spare tire carrier lift plate. I brought the vehicle to a Toyota dealership to have the recall addressed, but the dealership refused to perform the repair, stating that the frame is too rusted to proceed safely. They recommended a full frame replacement due to severe rust damage, which includes holes and significant structural weakening. Toyota has refused to provide a replacement frame under any existing recall or warranty program. This means the recall cannot be completed, and the vehicle remains unsafe to drive. Additionally, I cannot locate a replacement frame for this vehicle through Toyota or the aftermarket, leaving no practical solution to address the safety risks. The refusal to honor the recall and the lack of available replacement parts put me and others at significant risk. The problem has been confirmed by the Toyota dealership during inspection, and the rust damage makes the vehicle structurally unsound. The unresolved recall, combined with the excessive frame rust, has created a double safety hazard that needs urgent resolution”

“2011- check engine light was illuminated. Toyota dealership attempted repairs 11 times but could not find a cause. They replaced 7 different sensors, replaced gas cap, charcoal filter.. still could not get light to go off. refused to continue servicing same issue with no fault. Since 2011, I have had to run diagnostics on a regular basis to ensure there are no other mechanical issues. 2022- gas tank fell off of truck while driving. The straps snapped off due to rust and tank fell to the ground. This issue could have caused GREAT bodily injury or DEATH. 2023-lost brakes while driving. TOTAL brake failure. local mechanic stated it was a proportioning valve failure. The housing for it was rusted through and cannot be removed safely. After multiple days of research, a replacement could not be located. Even contacting Toyota, part is unavailable so vehicle CANNOT be fixed. Total brake failure could have led to GREAT bodily injury or DEATH. ONGOING-- vehicle frame is extremely rusted. bumper has fallen off, spare tire fell off, brush guard rusted and fell off. The frame under cab near bed of truck is rusted through. gas tank straps rusted through and tank fell off.…”

“The contact owns a 2004 Toyota Tacoma. The contact had taken the vehicle to Kolosso Toyota (3000 W Wisconsin Ave, Appleton, WI 54914) to have his exhaust replaced. While there, he was informed that the entire sub frame was corroded with several cracks and holes had formed around both front leaf springs. The mechanic informed him that the vehicle was unsafe to drive due to the failure. Prior to the failure, the contact took the vehicle to another local dealer where the vehicle was inspected under NHTSA Campaign Number: 05V225000 (Suspension). The contact was informed that a special coating was sprayed onto the sub frame to prevent corrosion; however, the recall remedy failed to prevent the corrosion. The manufacturer was contacted but provided no assistance. The vehicle was not repaired. The failure mileage was 51,641.”

“I was driving home from a neighboring city after picking up a friend and on my way there on the interstate I noticed the back end of the vehicle was very loose. Upon arriving at my apartment and parking the vehicle I contacted a friend who was a prior state safety inspector, he looked under the vehicle and said the frame right where the shackle for the leaf spring on the driver's side had completely blown out and was no longer connected. Checked the passenger side and said it was connected by maybe 1/4 of an inch of frame. I was made aware of a safety recall that expired back in 2019 by Hailey Toyota and was informed they would not fix it for free. Neither myself or the original owner had every received documentation regarding this issue and was never informed that the entire frame had to be replaced under the recall/extended warranty. I have shelled out well over $600 in materials and labor to have my frame welded and patched with a kit specifically made for these vehicles and this issue and I'm still having problems out of it.”

“The contact owns a 2004 Toyota Tacoma. The contact stated that while driving approximately 55 MPH, the passenger’s side axle fractured and the wheel detached. There were no warning lights illuminated. The vehicle was towed to an independent mechanic who replaced the ball joints. The local dealer was not contacted. On another occasion, while driving at an undisclosed speed, the driver’s side axle fractured and the wheel detached. The vehicle was towed to an independent mechanic who replaced the ball joints however, the failure recurred. The contact stated that the failure was related to NHTSA Campaign Number: 05V225000 (Suspension). The manufacturer was contacted but provided no assistance. The approximate failure mileage was 190,000.”